Benutzeranleitung / Produktwartung LP GAS GRILL des Produzenten Weber
Zur Seite of 52
SUMMIT ® W ARNING: Follow all leak-c heck procedures carefull y in this manual prior to barbecue operation. Do this e ven if the barbecue was dealer -assembled. NO TICE T O INST ALLER: These instructions must be left with the o wner and the owner should keep them f or future use .
A-2 Dangers & W arnings D ANGER Failure to f ollow the Danger s, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to pr oper ty .
A-3 Contents Danger & W arnings .................................................................................. A-2 W arranty .................................................................................................. A-4 General Instructions .
A-4 W eber-Stephen Products Co . (W eber) hereby warr ants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of def ects in mater ial and workmanship from the date of purchase as f ollows: when assembled and oper ated in accordance with the printed instr uctions accompanying it.
A-5 Gener al Instructions Y our W eber ® gas barbecue is a por table outdoor cooking appliance. With the Weber ® gas barbecue y ou can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer ® Bars produce that “outdoor” flav or in the f ood.
A-6 Gener al Instructions Grilling Methods NO TE: If grill looses heat while cooking refer to the tr oubleshooting section of this manual. W ARNING: Do not move the Weber ® gas barbecue when operating or while barbecue is hot. Y ou can adjust the Left and Right b ur ners in each b ur ner set as desired.
A-7 Exploded V iew 8 57 1 2 Summit ® Gold D LP 032103 14 19 22 23 24 26 33 34 36 37 38 39 40 41 42 44 48 49 50 51 65 70 73 74 75 76 77 79 84 85 86 87 88 89 90 93 54 32 59 9 10 13 12 52 4 6 7 15 18 25.
A-8 Exploded V iew List 1. Hinge Pin 2. Ther mometer Hardw are 3. Ther mometer Bez el 4. W ar m-Up ™ Basket 5. 8 inch Cooking Gr ate 6. Smok er Assembly 7. Smok er Box Chip Gr ate 8. Flav or izor ® Bar Assemb ly w/ Smok er 9. Rotisserie F or k 10. Rotisserie Motor 11.
A-9 P arts List Lid - 1 Cookbo x - 1 Left F rame Assemb ly - 1 Right F rame Assemb ly - 1 Side T ab le - 1 Side Bur ner - 1 Bottom Shelf - 1 Rear P anel - 1 Left Door - 1 Right Door - 1 W ar ming Rack.
A-10 LP T ank - 1 Catch-P an Holder - 1 Catch-P an - 1 Disposable Drip P ans - 2 Wrench - 1 7/16 inch Wrench - 1 Rotisserie Motor - 1 Rotisserie Brack et - 1 Flav or izor ® Bars - 2 Sets Smoker - 1 S.
B-a 1 Ba401.c a b c (1) (2) (3) (3) CA UTION: Bef ore proceeding to the ne xt step check that fr ame rail (2) is on the side with the s wing tables (3).
B-b 2 b a A TTENTION! Only start these bolts. Do not tighten yet..
B-c 3.
B-d b c a 1 2 4 A TTENTION! Completely remove both par tially started bolts from top rear frame rail A TTENTION! Reinstall both bolts thr ough rear panel and into rear frame rail.
B-e 5 a (1) (2) (2) (1) (2) (2) A TTENTION! Remo ve packing tape holding the gas line and brac ket(1). When installing cookbo x route the gas line and brac ket(1) inside the frame rails(2).
B-f (1) (2) (3) b 6.
B-g 7 (1) (2) (1) (2) c.
B-h 8 b a Matchlight Holder.
B-i 9 (1) (2) (3) a b.
B-j a b a b 10.
B-1 (1) (2) a b (1) B400_LP .c 11 NO TE: Igniter Wire (1) is located up under right side of control panel..
B-2 c d (1) (2) CA UTION: Hold burner cap (1) down while pushing side burner ignition wire (2) on..
B-3 a b 12 13.
B-4 14 15.
B-5 16 17.
B-6 6.
C-1 Gas Instructions Impor tant LP Cylinder Inf ormation F ailure to follow these D ANGER statements exactly ma y result in a fire causing death or serious injur y . D ANGER NEVER store a spare LP Cylinder under or near this barbecue. NEVER fill the tank bey ond 80% full.
C-2 Gas Instructions W e utilize v ar ious LP tank manuf acturers. Some of the tanks hav e diff er ing top collar assembles . (The top collar is the metal protective ring around the v alve .) One ser ies of tanks mount with the valv e facing front. The other tanks mount with the valv e facing a wa y from the fuel scale.
C-3 Gas Instructions (1) (2) (3) (2) (4) W ARNING : The gas connections of your Summit ® gas grill have been factory tesated. We do ho wever recommend that y ou leak check all gas connections before operating y our Summit ® gas grill. Remove contr ol panel P ar t required: Phillips Screwdriver .
C-4 Gas Instructions Chec k for gas leaks D ANGER Do not use an open flame to chec k for gas leaks. Be sure there are no sparks or open flames in the area while y ou chec k for leaks. Sparks or open flames will result in a fire or explosion, which can cause serious bodil y injury or death and damage to property .
C-5 Gas Instructions Reinstall control panel P ar ts required: control panel, screws , and burner control knobs. Place the control panel back onto the control panel brack ets on either side of the front of the cooking bo x. Line up screws with scre w holes on both the control panel and control panel brac kets.
C-6 Gas Instructions Liquid Propane Cylinder The liquid propane cylinder manuf acturer is responsible f or the materials, workmanship and performance of the tank. If the tank has a defect malfunctions , or you ha ve a question regarding the tank, call the tank manuf acturer ’ s customer ser vice center .
C-7 Gas Instructions Safe handling tips f or Liquid Propane Gas Cylinders ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas . LP gas is a gas at regular temperatures and pressures . Under moderate pressure, inside a cylinder , LP gas is a liquid.
D-1 Oper ating Instructions Grilling Methods NO TE: If grill looses heat while cooking refer to the tr oubleshooting section of this manual. Y ou can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O).
D-2 Oper ating Instructions Indirect cooking The Indirect Method is similar to roasting, b ut with the added benefits of that grilled texture , flav or , and appearance you can ’ t get from an o ven. T o set up f or Indirect cooking, gas burners are lit on either side of the f ood but not directly beneath it.
D-3 Oper ating Instructions Lighting Summar y lighting instructions are on the control panel. D ANGER Failure to open the lid while igniting the barbecue’ s burner s, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, ma y result in an explosive flame-up whic h can cause serious bodily injury or death.
D-4 Oper ating Instructions Manual Lighting D ANGER Failure to open the lid while igniting the barbecue’ s burners, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, may result in an e xplosive flame-up which can cause serious bodil y injury or death.
D-5 Oper ating Instructions Side Burner Lighting Instructions D ANGER F ailure to open the lid while igniting the side b urner , or not waiting 5 minutes to allow the gas to c lear if the side burner does not light, ma y result in an explosive flame-up which can cause serious bodily injury or death.
D-6 Oper ating Instructions (1) Using the Smoker The smoker uses presoak ed wood chips. For best results with f aster cooking foods lik e steaks, b urgers and chops, etc., we recommend using finer w ood chips because they ignite and create smok e faster .
D-7 Oper ating Instructions 1 8 4 5 7 4 2,3,9 6 Lighting the Smoker Burner W ARNING: Check hose before eac h use of grill for nicks, cracking, abrasions or cuts.
D-8 Oper ating Instructions 1 7,9 4 5 4 2,3,10 8 Manuall y Lighting the Smoker Burner W ARNING: Check hose before eac h use of grill for nicks, cracking, abrasions or cuts. If the hose is f ound to be damaged in any wa y , do not use the grill. Replace using only W eber ® authorized replacement hose.
D-9 Oper ating Instructions (1) (2) (1) Rotisserie Assembl y P ar ts required: rotisserie motor brack et(1), rotisserie motor(1), rotisserie shaft(1), spit forks(4) and f or k screws (4).
D-10 Oper ating Instructions Using the Rotisserie Note - Bef ore using your rotisserie, measure y our food at the widest point. If it exceeds 9 1/2 ” , it is too large to fit the rotisserie. If it is too large, f ood can be prepared using a roast holder and the Indirect Cooking Method.
D-11 Oper ating Instructions Lighting the Rotisserie Burner W ARNING: Check hose before eac h use of grill for nic ks, crac king, abrasions or cuts. If the hose is found to be dama ged in any wa y , do not use the grill. Replace using only a W eber ® authorized replacement hose.
D-12 Oper ating Instructions Manuall y Lighting the Rotisserie Burner W ARNING: Check hose before eac h use of grill for nic ks, crac king, abrasions or cuts. If the hose is found to be dama ged in any wa y , do not use the grill. Replace using only a W eber ® authorized replacement hose.
D-13 Pr oblem Chec k Cure Burner s burn with a yellow or orange flame, in conjunction with the smell of gas. Inspect W eber ® Insect / Spider screens f or possible instructions. (Blockage of holes .) Clean W eber ® Insect / Spider screens. (See Section “ Annual Maintenance ” ) Burner s do not light.
D-14 Pr oblem Chec k Cure Side Burner does not light. Flame is low in HIGH position. Push button ignition does not work. Is gas supply off? T ur n supply on. Is the fuel hose bent or kink ed? Straighten hose . Does burner light with a match? If match lights b ur ner , checkigniter (see below).
D-15 Rotisserie T r oubleshooting Pr oblem Chec k Cure Burner does not light. Did you hold the b urner control knob down and hold do wn for 20 seconds until after burner ignited? T r y to relight burner by holding burner control knob down and continue holding do wn until 20 seconds after burner has ignited.
E-1 Maintenance (1) (1) Main Burner Flame P attern The W eber ® gas barbecue burners hav e been factory set f or the correct air and gas mixture. The correct flame pattern is shown.
E-2 Maintenance Replacing Main Burners 1. Y our Summit ® gas grill must be OFF and cool. 2. T ur n gas OFF at source. 3. Disconnect regulator . 4. Remov e cooking grates . 5. Remov e Smoker bo x. 6. Remov e Flav orizer ® bars. 7. T o remov e control panel refer to “Remove the control panel” under “Check f or Gas Leaks.
E-3 Maintenance 12. Lift and twist the burner assembly slightly , to separate the Crossov er ® tube (a) from the burners (b). 11. Pull manif old assembly out from the manif old frame. (a) (b) (b) 13. Remov e the Crossov er ® tube. 14. Pull the selected burner(s) tube(s) from manif old frame and replace with a ne w burner tube.
E-4 Maintenance Cr ossover ® Ignition System Operations If the Crossov er ® ignition system f ails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossov er ® ignition system.
Ein wichtiger Punkt beim Kauf des Geräts Weber LP GAS GRILL (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Weber LP GAS GRILL noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Weber LP GAS GRILL - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Weber LP GAS GRILL reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Weber LP GAS GRILL erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Weber LP GAS GRILL besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Weber LP GAS GRILL verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Weber LP GAS GRILL. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Weber LP GAS GRILL gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
