Benutzeranleitung / Produktwartung LD485RSIB des Produzenten Napoleon Grills
Zur Seite of 40
N a p o l e o n A p p l i a n c e C o r p . , 2 1 4 B a y v i e w D r . , B a r r i e , O n t a r i o , C a n a d a L 4 N 4 Y 8 P h o n e : 1 - 8 6 6 - 8 2 0 - 8 6 8 6 F a x : ( 7 0 5 ) 7 2 5 - 2 5 6 4 email: wecare@napoleonpr oducts.com web site: www .
2 www .napoleongrills.com Napoleon Gas Grill Pr esident ’ s Limit ed W arr anty NAPOLEON w arran ts the follo wing materials and w orkmanship in your new NAPOLE ON gas grill agains t def ects f or twenty v e year s.
3 www .napoleongrills.com W ARNING! F ailure to f ollow these instrucons could r esult in property damage, per sonal injury or death. R ead and follow all warnings and ins trucons in this manual prior to oper ang grill.
4 www .napoleongrills.com Cylinder Specica on/Gas Hook Up THIS GAS BARBECUE IS CERTIFIED UNDER CANADIAN AND AMERICAN NA TIONAL ST ANDARDS, CAN/CSA -1.6- 2005 AND ANSI Z21.58 -2005 RESPECTIVEL Y FOR OUTDOOR GAS GRILLS AND SHOULD BE INST ALLED TO CONF ORM WITH LOCAL C ODES.
5 www .napoleongrills.com Leak T es ng Instrucons W ARNING! A leak test mus t be performed annually and each me a cylinder is hook ed up or if a part of the gas s yst em is replaced. W ARNING! Never use an open ame to check f or gas leak s.
6 www .napoleongrills.com Lighng Ins trucons O Posion W ARNING! Open lid W ARNING! Ensure all burner con trols are in the o posion. T urn on the gas supply valve. Main T ube Burner Lighng Rear Burner Lighng (Rosserie Burner) Side Burner Lighng (If equipped) 1.
7 www .napoleongrills.com Oper ang The Grill Inial Lighng : When lit f or the rst me, the g as grill emits a slight odor . This is a normal tempor ary condion caused by the “burn-in” of int ernal paints and lubricants used in the manuf acturing process and does not occur again.
8 www .napoleongrills.com 1. Follow the infr ared side burner ligh ng instrucons and opera te on high f or 5 minutes with the lid opened or unl the cer amic burners glow r ed. 2. Place food on grills and c ook according to mes lis ted in the Infr ared Grilling Chart.
9 www .napoleongrills.com Infr ared Grilling Chart Food Control Se ng Cooking Time Helpful Suggesons Steak 1 in. thick High seng 2 min. each side. High seng 2 min. each side then medium seng. High seng 2 min. each side then medium seng.
10 www .napoleongrills.com W ARNING! Alwa ys wear prot ecve gloves and saf ety glasses when cleaning your grill. W ARNING! T o avoid the possibility of burns, maint enance should be done only when the grill is cool. Av oid unprotect ed cont act with hot surfaces.
11 www .napoleongrills.com Grids And W arming Rack : The grids and warming r ack are best cleaned with a br ass wire brush during the pre-heang period.
12 www .napoleongrills.com T r oubleshoong Problem Possible Causes Soluon Low heat / Low ame when valve turned t o high. For pr opane - improper lighng pr ocedure. For natur al gas - under sized supply line. For both g ases - improper prehea ng.
13 www .napoleongrills.com Problem Possible Causes Soluon Flames li awa y from burner , accompanied by the smell of gas, and possibly dicules in lighng. Improper air shuer adjus tment. Close air shuer slightly accor ding to combuson air adjus tment instrucons.
14 www .napoleongrills.com KEEP Y OUR RE CEIPT AS PROOF OF PURCHASE T O V ALID A TE Y OUR W ARRANTY . Or dering R eplacement P arts W arranty Informaon MODEL: DA TE OF PURCHASE: SERIAL NUMBER: (Rec.
15 www .napoleongrills.com CAUTION ! During unpacking and assembly we r ecommended you wear w ork gloves and saf ety glasses for y our protecon. Although we mak e every eort to mak e the assembl.
16 www .napoleongrills.com 2. Cast er/Br ack et Ins talla on A ach (4) cast ers, using (4) ¼ -20 x 3/8” scr ews and (4) ¼ -20 lock nuts for each c aster . A ach br ack ets under fron t caster s as illustr ated. Tigh ten securely . 1. Magnet Ins talla on Snap magnet into slot in fr ont of boom shelf .
17 www .napoleongrills.com Pr opane Only 4 x N570-0080 (#14 x 1/2”) 3/8”(10mm) 3. Propane T ank Ring Ins talla on Insert propane t ank ring into slots in boom of shelf as shown.
18 www .napoleongrills.com 6 x N570-0080 (#14 x 1/2”) 3/8”(10mm) 5. R ear Cart P anel Inst alla on Fit rear cart panel be tween the two end panels; ensure lar ge hole in panel is to the bo om right corner as illustr ated. F asten using (6) #14 x 1/2” scre ws, three on each side.
19 www .napoleongrills.com 6. T ank Inhibitor Br ack et / Pr opane T ank Mount Ins talla on Insert tank inhibitor br ack et int o slot in rear panel as illustr ated. F ast en to boom panel using (1) #14 x 1/2” scre w . Clip top pr opane tank mount int o slots in back panel.
20 www .napoleongrills.com 4 x N570-0080 (#14 x 1/2”) 3/8”(10mm) 4 x N570-0080 (#14 x 1/2”) 1 X N430-0002 7. Fron t Cabinet Support Ins tallaon F asten top r ail assembly to the fr ont of side panels using (4) #14 x 1/2” screw s. For ease of inst allaon st art all screws be for e ghtening c ompletely .
21 www .napoleongrills.com 3/8”(10mm) Incorr ect Assembly Correct Assembly 4 x N570-0091 (1/4-20 X 1/2”) 9. Grill Head Ins talla on PROP ANE ONL Y – T o av oid assembly dicules, prior to mounng the grill head, remo ve zip e holding regula tor up under contr ol panel.
22 www .napoleongrills.com 3/8”(10mm) 2 x N570-0073 (1/4-20 X 3/8”) 10. Ba ery P ack / R osserie Mount Ins t allaon Install ba ery pack below ven t slots on le hand panel using magnet supplied with baery pack. Plug wir e from LED (lights) locat ed underneath contr ol panel into wir e from ba ery pack.
23 www .napoleongrills.com 8 x N570-0076 (#8 X 1/2”) 11. Side Shelf Assembly Peel the pr otecve c oang from the side shelf . Insert the top of the side shelf into the end cap eng aging the edge of the shelf under the ribs in the end cap as illustr ated.
24 www .napoleongrills.com 4 x N570-0082 (1/4-20 X 5/8”) 3/8”(10mm) 4 x N735-0001 (insulated washer) 12. Side Shelf Ins talla on Insert (4) 1/4 - 20 x 5/8” screw s through the washer s into the thr eaded holes in the side of the base; do not ghten all the wa y .
25 www .napoleongrills.com Cooking Grid Placement: The cooking grid can be placed a t two di erent heights. The low er height is for use with pots or pans. The higher posion is to be used when searing meats. Ensur e the burner is o and the grid is cool to the t ouch befor e changing between the two heigh ts.
26 www .napoleongrills.com 4 x N570-0099 (#14 x 3/4”) 3/8”(10mm) 4 x N340-0007 (tool hook) 14. Door Assembly Install the door handle on to the fron t of the door and the tool hooks ont o the back of the door using (2) #14 x 3/4” screws per door .
27 www .napoleongrills.com Bushing 2 x N160-0022 (pivot pin clip) 2 x N105-0011 (door bushing) 1 2 15. Door Inst alla on Firs t direct the pivot pin int o the hole in the underside of the fr ont cabinet support and then lower the door in to the bushing in the boom shelf .
28 www .napoleongrills.com 17. Sear Plat e Ins talla on Insert sear plates in to base, posion one over each tube burner with slots down t o allow drippings to tra vel thr ough. 18. Grids and W arming Rack Inst alla on Posion grids and w arming rack int o base as shown.
29 www .napoleongrills.com 18. Grids and W arming Rack Inst alla on Posion grids and w arming rack int o base as shown. Res t warming r ack on brack ets inside hood and grids on fr ont and back lip of base.
30 www .napoleongrills.com 20. Drip P an Ins talla on Slide drip pan into r ear of base as shown. Ensure dip pan rides along r ails on boom of base.
31 www .napoleongrills.com R osserie Kit Assembly Instrucon (oponal) Assemble rosserie kit componen ts as shown. Ensure s top bushing is ght ened on the inside of hood casng.
32 www .napoleongrills.com Propane Only – Proper Hose Connecon Ensure the r egulator dr ops int o the small opening, between the tank hea t shield and the right side of the cabine t.
33 www .napoleongrills.com Natural Gas Only – Proper Hose Connecon 3/4”(19mm) Clip hose to side panel using hose ret ainer clip supplied. W ARNING! The installa on must be performed b y a licensed gas er , and all connecons must be leak test ed befor e opera ng the grill.
34 www .napoleongrills.com Natural Gas Only – Improper Hose Connecon W ARNING – FIRE HAZ ARD W ARNING! Do not route hose o ver top of rear panel. W ARNING! Do not route hose undernea th drip pan. W ARNING! Ensure the hose does not con tact any high t empera ture surfaces, or it ma y melt and leak causing a re.
35 www .napoleongrills.com Leak T es ng Instrucons W ARNING! A leak test mus t be performed annually and each me a cylinder is hook ed up or if a part of the gas s yst em is replaced. W ARNING! Never use an open ame to check f or gas leak s.
36 www .napoleongrills.com Item Part # Descripon RSIB 1 N135-0042-GY1HT le side lid casng x 2 N385-0129 NAPOLEON logo x 3 W450-0005 logo spring clips x 4 N510-0010 black silicone lid bumper x.
37 www .napoleongrills.com Item Part # Descripon RSIB 39 N051-0006 control knob bez el x 40 N530-0003 1-outlet regulator p N345-0001 10 n/g hose c/w quick disconnect n 41 N010-0716 manifold asse.
38 www .napoleongrills.com Item Part # Descripon RSIB 79 N570-0042 10-24 x 3/8” screw x 80 N455-0062 side burner orice #60 p N455-0063 side burner orice 1.
39 www .napoleongrills.com.
40 www .napoleongrills.com FAX TO: 705 727 4282 CONTACT NA ME:_________________________ ______________________ _________________ ______ SHIP TO :____________________ _________________ ________________.
Ein wichtiger Punkt beim Kauf des Geräts Napoleon Grills LD485RSIB (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Napoleon Grills LD485RSIB noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Napoleon Grills LD485RSIB - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Napoleon Grills LD485RSIB reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Napoleon Grills LD485RSIB erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Napoleon Grills LD485RSIB besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Napoleon Grills LD485RSIB verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Napoleon Grills LD485RSIB. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Napoleon Grills LD485RSIB gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
