Benutzeranleitung / Produktwartung KC42N des Produzenten Desa
Zur Seite of 44
For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol- .
www .desatech.com 1 16239-01F 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 2 Product Identication ........................................... 4 Local Codes..............................
www .desatech.com 1 16239-01F 3 This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system.
www .desatech.com 1 16239-01F 4 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone.
www .desatech.com 1 16239-01F 5 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent replace: • The venting system may be routed to the out - side of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/exterior wall (horizontal).
www .desatech.com 1 16239-01F 6 • When locating termination cap, it is important to observe the minimum clearances shown in Figure 7, page 8. • If recessing into a wall, you can avoid extra framing by positioning your replace against an already existing framing member .
www .desatech.com 1 16239-01F 7 A B E F G H D C Nailing T abs C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 W all Figure 5 - Framing Clearances for Corner Installation Mantel .
www .desatech.com 1 16239-01F 8 Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12" (30.
www .desatech.com 1 16239-01F 9 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc- .
www .desatech.com 1 16239-01F 10 INST ALLA TION PLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop.
www .desatech.com 1 16239-01F 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess 6.
www .desatech.com 1 16239-01F 12 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screw.
www .desatech.com 1 16239-01F 13 CORNER INST ALLA TION Recommended Applications: • Corner ground oor installation • G ro un d o or in st a ll at io n w h er e p i p e v en t s ho ri z o n -.
www .desatech.com 1 16239-01F 14 VENTING INST ALLA TION INSTRUCTIONS Continued Horizontal (H 1 Horizontal (H 1 Horizontal (H 2 5' min.
www .desatech.com 1 16239-01F 15 INST ALLA TION FOR VERTICAL TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1.
www .desatech.com 1 16239-01F 16 5. Pla ce th e as hing ov er th e pip e se ction (s) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing nails. Be sure roo ng materia l over laps the top edge of the ashing as shown in Figure 19, page 15.
www .desatech.com 1 16239-01F 17 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown. V ertical (V 1 5' min.
www .desatech.com 1 16239-01F 18 AND COMPONENTS .
www .desatech.com 1 16239-01F 19 FIREPLACE INST ALLA TION Us e pro per ga s typ e for the r ep la ce un it yo u are in st al li ng . If you hav e co n ic ti ng gas typ es , do not in st al l re plac e.
www .desatech.com 1 16239-01F 20 CA UTI ON: Nev er to uc h th e 9. Ch ec k to mak e sur e th at the pow er cor d is com - pl et el y cl ea r of t he b lo we r wh ee l an d t hat t he re ar e no oth er for ei gn obj ect s in bl ow er whe el.
www .desatech.com 1 16239-01F 21 7. Che ck to ma ke su re t ha t th e po we r co rd is c om - pl ete ly c lea r of th e b low er w he el a nd t ha t th ere a re no ot he r f or ei gn o bj ec ts i n b lo we r wh ee l .
www .desatech.com 1 16239-01F 22 Figure 31 - External Regulator with V ent Pointing Down (Propane/LP Only) Propane/LP Supply T ank External Regulator V ent Pointing Down CAUTION: Use only new , .
www .desatech.com 1 16239-01F 23 Figure 33 - Connecting Flexible Gas Line to Millivolt V alve Flexible Gas Line Do NOT Kink Equipment Shutoff V alve T o Gas Supply (Natural) T o External Regulator (Pr.
www .desatech.com 1 16239-01F 24 PRESSURE TESTING FIREPLACE GAS CONNECTIONS 1. Open equipment shutof f valve (see Figure 34, page 23). 2. O pe n p r op a ne / L P s up p l y t an k v al v e f o r propane/LP fireplace or main gas valve located on or near gas meter for natural gas replace.
www .desatech.com 1 16239-01F 25 Held Remote Control Unit 1. Remove battery cover on back of remote control unit. 2. Attach terminal wires to a 9-volt alkaline battery (not included).
www .desatech.com 1 16239-01F 26 4. Remount the new frame at the hinge with ve new s crew s bef ore c losin g do or . Th is wi ll ensure seating of the gasket. 5. Cl os e g la ss d oo r fr am e. L oc k l at che s by p la ci ng th e ba r u nd e r th e ta b o n d oo r a nd p u sh in g dow n an d bac k on la t ch ( se e F ig ur e 42, pa ge 2 5).
www .desatech.com 1 16239-01F 27 8. Install rear brick panel rst. Rest bottom edge of panel on back edge of burner assembly (see Figure 44). 9. Install left side brick panel by sliding it be - tween the burner assembly and the side of the rebox (see Figure 44).
www .desatech.com 1 16239-01F 28 7. Turn gas control knob counterclockwise t o PIL OT . ( se e Fi gu r e 45 ). 8. Push in gas control knob all the way and hold. Immediately light the pilot by repeat- edly depr essing the piezo spar k igni tor unti l a ame appears .
www .desatech.com 1 16239-01F 29 OPERA TING FIREPLACE Continued Hold the control button on the hand-held remote until burner turns on. Hold the con- trol button again until burner turns off (see Figure 47).
www .desatech.com 1 16239-01F 30 Th is fea ture al lo ws the use r to lo ck /u nl oc k the ke ypa d on the han d- he ld rem ote in th e MA NU or A UT O mo de to pr ev en t in ad ve rt en t o pe ra ti on ( i.
www .desatech.com 1 16239-01F 31 INSPECTING B URNERS Continued Burn er ames will be steady; not lifti ng or oat ing. Flame patterns will be different from unit to unit and will vary depending on installation type and weather conditions.
www .desatech.com 1 16239-01F 32 CAUTION: Do not vacuum if Use only the tempered glass door replacement intende d for this replace (see Replacement Parts , page 37 for detail on ordering). No substitutions may be made.
www .desatech.com 1 16239-01F 33 TROUBLESHOO TING .
www .desatech.com 1 16239-01F 34 Pilot lights but ame goes out when control knob is released Burner does not light after pilot is lit Delayed ignition burner Burner backring during com - bustion Slight smoke or odor during initial operation REMEDY 1 .
www .desatech.com 1 16239-01F 35 TROUBLESHOO TING Continued Heater produces a whistling noise when burner is lit Glass soots Fir epla ce produ ces a clicki ng/t ick - ing noise just after burners are lit or shut off Remote does not function REMEDY 1.
www .desatech.com 1 16239-01F 36 TROUBLESHOO TING Continued .
www .desatech.com 1 16239-01F 37 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty .
www .desatech.com 1 16239-01F 38 ILL USTRA TED P ARTS BREAKDOWN .
www .desatech.com 1 16239-01F 39 P ARTS LIST This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 37 of this manual.
www .desatech.com 1 16239-01F 40 ILL USTRA TED P ARTS BREAKDOWN .
www .desatech.com 1 16239-01F 41 P ARTS LIST SERIES This list contains replaceable parts used in your replace.
www .desatech.com 1 16239-01F 42 Man ual vari abl e contro l blowe r acces sory pro vide s better heat distribution. Complete installation and operation instructions included in this manual.
www .desatech.com 1 16239-01F 43 ACCESSORIES Continued RE CEI VE R AND H AN D-H EL D ON/ OF F SERIES Al lo ws t he fi re pl ac e to b e t ur ned o n a nd o ff con ven ient ly .
2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16239-01 Rev . F 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory .
Ein wichtiger Punkt beim Kauf des Geräts Desa KC42N (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Desa KC42N noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Desa KC42N - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Desa KC42N reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Desa KC42N erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Desa KC42N besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Desa KC42N verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Desa KC42N. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Desa KC42N gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
