Benutzeranleitung / Produktwartung 463821908 des Produzenten Char-Broil
Zur Seite of 28
THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have any questions or need assistance during assembly , please call 1-800-241-7548. T o insure your satisfaction and for follow-up service, register your grill online at www.
2 • 463821908 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not er not connected for use shall not be stored in the vicinity of this or any other WARNING CA UTION For residential use only.
T ABLE OF CONTENTS F o r Y o u r S a f e t y ......................................2 G r i l l S e r v i c e C e n t e r ...................................2 P r o d u c t R e c o r d I n f o r m a t i o n ............................2 Installation Safety Precautions .
• NEVER store a spare LP tank under or near the appliance or in an enclosed area. • Never fill a tank beyond 80% full. • An over filled or improperly stored tank is a hazard due to possible gas release from the safety relief valve.
WARNING If “growing” bubbles appear do not use or move the LP tank. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP tank 1. LP tank must be properly secured onto grill. (Refer to assembly section.) 2. T urn all control knobs to the OFF position.
6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP tank valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection.
For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly .
CA UTION If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.
Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP tank. 2. vaporiser b 3. 4. 5. 6. 7. 8. VERY IMPORTANT: Burner tubes must reengage valve openings.
Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry .
463821908 • 1 1 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, .
12 • 463821908 P ARTS DIAGRAM – Model No. 463821908 Q EE H R CC DD S BB AA A V U T P Y Z W M C G I N E D GG FF J L K O X B HH II F F.
463821908 • 13 2 ASSEMBL Y – Model No. 463821908 1 Attach back support brace to legs with (4) #10-24x2" carriage bolts and #10-24 Plastic wing nuts . A Attach right leg assembly to bottom shelf with (2) #10-24x2" carriage bolts and #10-24 Plastic wing nuts .
14 • 463821908 3 4 A Place bottom of front panel into three slots in the bottom shelf. B Attach front panel to legs with four #10-24x2" machine screws a n d #10-24 flange nuts . A Place valve/hose/regulator onto control panel. Attach with machine screws .
463821908 • 15 5 6 Attach control panel to firebox using #10-24 x ½” machine screws, silicon washers an d #10-24 flange nuts. #10-24 Flange Nut Qty. 4 A Place firebox onto cart, make sure the regulator hose hangs inside cart and control panel overlaps front panel.
7 A Attach tool holder to front leg using two #10-24x2" machine screws and #10-24 flange nuts . Place sideburner pan into frame and attach with a #10-24x2" carriage bolt and #10-24 metal wing nut in back and a T-wing screw in front. B Attach sideburner valve cup.
9 Attach lower lid hinges to back of firebox using #10-24x1/2" machines screws , silicon washers a n d #10-24 flange nuts per hinge. The center flat portion of the hinge should be at the bottom (see inset).
10 Attach handle to front of lid with silicon washers , insulation washers a n d #10-24 wing nuts . Upper lid hinges attach to back with #10-24x1/2" machine screws, fiber washers an d #10-24 flange nuts .
463821908 • 19 A Insert ends of Swing Away pivot wire into holes in sides of grill lid. Insert ends of Swing Away leg wire into holes in sides of firebox. NOTE: Pivot and leg wires, running side-to-side, should be under wires running front-to-back. If pivot and leg wires are on top Swing Away is installed upside-down.
13 Insert tank wire into holes in bottom shelf of the cart. Tank Wire Hang grease cup clip from bottom of firebox and place grease cup into grease clip. bottom of tank into bottom shelf. Rotate tank wire up to secure tank. L P t a n k I S S O L D S E P A R A T E L Y .
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP tank. Gas leaking from LP tank valve. Gas leaking between LP tank and regulator connection.
Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor . Burner(s) will not match light. Low flame, drop in gas flow . Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)). Unable to fill LP tank.
Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
24 • 463821908 Page intentionally blank.
463821908 • 25 Page intentionally blank.
26 • 463821908 Page intentionally blank.
Please register your grill online at: (If you register online, you do not need to send in this registration card.) WWW .GRILLREGISTRA TION.COM Chimenea / Envíelo a: La parrilla estaba ensamblada 4638.
Char-Broil, LLC Printed in China • Columbus, GA 31902 • ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete.
Ein wichtiger Punkt beim Kauf des Geräts Char-Broil 463821908 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Char-Broil 463821908 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Char-Broil 463821908 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Char-Broil 463821908 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Char-Broil 463821908 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Char-Broil 463821908 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Char-Broil 463821908 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Char-Broil 463821908. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Char-Broil 463821908 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
