Benutzeranleitung / Produktwartung Portable Spas des Produzenten Cal Spas
Zur Seite of 52
L TR20091001, Rev . A 12/15/08.
Read This First! Important Safety Instructions .................. 3 Basic Spa Information ........................ 3 Preparing for Y our New Portable Spa Planning the Best Location .................... 5 Preparing a Good Foundation ................. 5 230 V olt Electrical Installation .
2009 Portable Spa Owner ’s Manual Page 3 L TR20091001, Rev . A Read This First! Read This First! Important Safety Instructions When installing and using this electrical equipment, always follow basic safety precautions. Following these instructions will help make your rst spa session a pleasurable one.
Page 4 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Read This First! In addition to the water pressure, you can add air into the spa water with air venturi handles located seat-side that increase the intensity of your massage. The ltering of this spa is very important.
2009 Portable Spa Owner ’s Manual Page 5 L TR20091001, Rev . A Preparing for Y our New Portable Spa Preparing for Y our New Portable Spa Most cities and counties require permits for exterior construction and electrical circuits.
Page 6 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Preparing for Y our New Portable Spa 230 V olt Electrical Installation All 230V spas must be permanently connected (hardwired) to the power supply . These instructions describe the only acceptable electrical wiring procedure.
2009 Portable Spa Owner ’s Manual Page 7 L TR20091001, Rev . A Preparing for Y our New Portable Spa Electrical Installation for 8.5 kW Heater This applies to Ultimate Fitness spas with the 8.5 kW heater only . T wo electrical services are required to heat the swim side of the Fitness Spa.
Page 8 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Preparing for Y our New Portable Spa RCD Wiring Diagram RCD Device.
2009 Portable Spa Owner ’s Manual Page 9 L TR20091001, Rev . A Preparing for Y our New Portable Spa Gas Heater Hook-up Ultimate Fitness Series spa owners may buy and install a separate gas heater and pump for use with their spa. This option may be purchased separately from your local distributor .
Page 10 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Preparing for Y our New Portable Spa.
2009 Portable Spa Owner ’s Manual Page 1 1 L TR20091001, Rev . A Preparing for Y our New Portable Spa Filling and Powering Up Y our Portable Spa Once the water is at the correct level and air is bled, 7.
Page 12 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Operating Y our Spa Initial Start up When rst powered up, it will automatically revert to Priming mode.
2009 Portable Spa Owner ’s Manual Page 13 L TR20091001, Rev . A Operating Y our Spa Diagnostic Messages Message Meaning -- Spa temperature is unknown. After pump has been running for 2 minutes temperature will be displayed. HH Overheat protection (spa is shutdown) DO NOT ENTER THE W A TER! One sensor has detected 1 18˚F (48˚C) at the heater .
Page 14 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Operating Y our Spa LF This will display on the 5th occurrence of the “HL” message in 24 hours indicating a persistent ow problem. The heater will be shut down but other functions will continue to operate.
2009 Portable Spa Owner ’s Manual Page 15 L TR20091001, Rev . A Operating Y our Spa When rst powered up, the electronic system will perform a self-diagnostic check and then it will automatically heat to and maintain a temperature of 37.5˚C until you change the set temperature as listed in the “T emperature Adjustment” section below .
Page 16 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Operating Y our Spa turns on automatically , it cannot be deactivated from the panel; however , the high speed may be started. Option (Optional Blower) Press the OPTION button to turn the optional equipment on and off.
2009 Portable Spa Owner ’s Manual Page 17 L TR20091001, Rev . A Operating Y our Spa Periodic Reminder Messages Press the “Mode” button to reset a displayed reminder) Message Frequency Action Required rPH Every 7 days T est and adjust chemical levels per manufacturer ’s instructions.
Page 18 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Operating Y our Spa LF Persistent low ow problems. (Displays on the fth occurrence of the “HFL” message within 24 hours.) Heater is shut down, but other spa functions continue to run normally .
2009 Portable Spa Owner ’s Manual Page 19 L TR20091001, Rev . A Operating Y our Spa Auxiliary Control Operation The auxiliary control option is available with the 8005 control only . It is a small panel with four buttons: JETS1, JETS2, LIGHT , and OPTION (see gure at right).
Page 20 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Operating Y our Spa Diverter Knobs Diverter knobs are the larger knobs located around the top of your spa. They allow you to divert water through jets from one side of the spa to the other , or in most cases from oor jets to wall jets.
2009 Portable Spa Owner ’s Manual Page 21 L TR20091001, Rev . A Operating Y our Spa second 15-minute session, the system will run through a cool down cycle for up to two hours. In this cool down mode, the user will only be able to operate the pump (by again pressing the “PUMP ON/OFF” button).
Page 22 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A W ater Quality Maintenance W ater Quality Maintenance Cal Spas Clear W ater Plan Great spa water is easily achieved when the right chemicals and / or systems are used and the Cal Spas “Clear W ater Plan” is implemented.
2009 Portable Spa Owner ’s Manual Page 23 L TR20091001, Rev . A W ater Quality Maintenance Chemical Safety Failure to follow chemical directions may result in • serious injury , sickness, or even death. Read and follow all printed instructions listed on • bottles, packages and in your owner ’s manual.
Page 24 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A W ater Quality Maintenance Chemical Descriptions The following descriptions and recommendations are intended for use with Cal Spas chemicals only . Many of these chemicals will be used with alternative sanitation systems as well.
2009 Portable Spa Owner ’s Manual Page 25 L TR20091001, Rev . A W ater Quality Maintenance For use with the chlorine “Clear W ater Plan” Chlorinating Granules Quick acting sanitizer / disinfectant for spa water . T est Strips – Chlorine Provides accurate spa water testing for Bromine, pH, and total Alkalinity .
Page 26 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A W ater Quality Maintenance T raditional Chemical Start Up Prior to lling a spa for the rst time, or after a routine draining, you will want to follow this start-up plan to extend water life and performance.
2009 Portable Spa Owner ’s Manual Page 27 L TR20091001, Rev . A W ater Quality Maintenance Chlorine Clear W ater Plan This plan and its chemical dosages are intended for Cal Spas chemicals only . Most chemical manufacturers use different chemical formulas and strengths.
Page 28 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A W ater Quality Maintenance Bromine Generator Clear W ater Plan This plan and its chemical dosages are intended for spas equipped with the optional Cal Clarity Automatic Bromine Generator .
2009 Portable Spa Owner ’s Manual Page 29 L TR20091001, Rev . A W ater Quality Maintenance Use Sodium Bromide T est Strips (not Bromine) and 12. adjust sodium bromide level to 7.4 to 8.2 (equates to 1700 to 2500 ppm TDS / conductivity level). Add 2 oz.
Page 30 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Cleaning and Maintenance Cleaning and Maintenance Removing and Reseating the Pillows Y ou can remove the pillows for cleaning and maintenance quickly and easily . This method works for all types of pillows.
2009 Portable Spa Owner ’s Manual Page 31 L TR20091001, Rev . A Cleaning and Maintenance Draining Y our Portable Spa Y our spa should be drained every four to six months, and relled with fresh tap water . The following is the recommended method for draining your spa.
Page 32 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Cleaning and Maintenance W arning: Do not use automotive vinyl protectants on spa covers or pillows. These products are generally oil- based and will cause severe water clarity issues that are difcult to correct.
2009 Portable Spa Owner ’s Manual Page 33 L TR20091001, Rev . A Cleaning and Maintenance can accumulate dirt, oil, and calcium, causing a rough feel and unsightly scum lines. Cal Spas™ Fast Sheen is a non-oil based wax that is specically formulated to protect the spa’s nish from the chemicals and minerals associated with normal spa use.
Page 34 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Using the Entertainment System Some spas may be equipped with audio/visual entertainment options. Several options are available and include marine grade CD players, DVD players, and an iPod ® docking station.
2009 Portable Spa Owner ’s Manual Page 35 L TR20091001, Rev . A Using the Entertainment System Use the remote control to navigate the DVD menu 4. using the fast forward and fast reverse buttons located at the lower part of the universal remote. T o remove the disk, press the OPEN button on the DVD 5.
Page 36 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Using the Entertainment System Programming the Universal Remote Control The Cal Spas universal remote has been pre- programmed to function with the entertainment system the spa has been congured with.
2009 Portable Spa Owner ’s Manual Page 37 L TR20091001, Rev . A Appendix Appendix Replacement Parts Jet T ype Description Standard Gray Face Stainless Steel Face CXL W 6.
Page 38 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix MJL W 6.5”, POWER STORM JET , DIRECTIONAL PLU21703422 PLU21703625 MJW 5.5”, POWER STORM JET , DIRECTIONAL PLU21703423 PLU21703600 MNW 2.
2009 Portable Spa Owner ’s Manual Page 39 L TR20091001, Rev . A Appendix SXW 5.5”, POWER STORM JET , SWIRLEY PLU21703424 PLU21703623 TW 4.75”, POWER SWIM JET TORNADO PLU21703428 PLU21703629 W WH.
Page 40 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix V alves PLU21300052 DIVERTER V AL VE 1” (2 WA Y) SIL VER, TEARDROP HANDLE (2 TONE) PLU21300062 DIVERTER V AL VE 2” (2 WA .
2009 Portable Spa Owner ’s Manual Page 41 L TR20091001, Rev . A Appendix Filters FIL1 1 100190 FIL TER CARTRIDGE, 50 SQ FT . ANTI-BACTERIAL RED FIL1 1 100191 FIL TER CARTRIDGE, 75 SQ FT . ANTI-BACTERIAL WHITE FIL1 1 100193 FIL TER CARTRIDGE, 35 SQ FT .
Page 42 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix Covers A valon Series A515/A526/A534 - 84 x 64 Standard Rust ACC01200460 Standard Gray ACC01200461 Standard Slate ACC01200464.
2009 Portable Spa Owner ’s Manual Page 43 L TR20091001, Rev . A Appendix CLASSIC/LEGACY NEWPORTER - 93 x 130 Standard Rust ACC01200450 Standard Gray ACC01200451 Standard Slate ACC01200452 Standard P.
Page 44 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix DIJ-404 - 93 x 130 Deluxe Rust ACU02200339 Deluxe Gray ACU02200343 Deluxe Slate ACU02200344 Deluxe Palomino ACU02200338 Delux.
2009 Portable Spa Owner ’s Manual Page 45 L TR20091001, Rev . A Appendix FII530 - 84 x 64 Standard Rust ACC01200460 Standard Gray ACC01200461 Standard Slate ACC01200464 Standard Palomino ACC01200466.
Page 46 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix VX834B/L, VX848B/L, VX860B/L - 93 x 93 Standard Rust ACC01200420 Standard Gray ACC01200421 Standard Slate ACC01200422 Standar.
2009 Portable Spa Owner ’s Manual Page 47 L TR20091001, Rev . A Appendix Keeping Fit with your Cal Spa IMPORT ANT : Always consult your physician before starting any exercise activity or program. The tness series spas feature rubber exercise bands.
Page 48 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix Connecting the Exercise Equipment The drawings below show different ways the exercise kit can be connected depending on the exercises you wish to do.
2009 Portable Spa Owner ’s Manual Page 49 L TR20091001, Rev . A Appendix Cal Spas™ Chemicals.
Page 50 2009 Portable Spa Owner ’s Manual L TR20091001, Rev . A Appendix 2009 W arranty International Portable Spas All Cal Spas portable spas are warranted to be free from defects in material and workmanship at the time of delivery .
2009 Portable Spa Owner ’s Manual Page 51 L TR20091001, Rev . A Appendix Proration of W arranty Units determined by the Company to be non-repairable will be replaced on a prorated basis with the same or a comparable unit.
Locating the product serial number The serial number of your Cal Spa is located on a metal plate attached to the lower right front panel of the spa.Y ou will need this number to properly register your spa and activate coverage. Write this information in the space provided below .
Ein wichtiger Punkt beim Kauf des Geräts Cal Spas Portable Spas (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Cal Spas Portable Spas noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Cal Spas Portable Spas - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Cal Spas Portable Spas reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Cal Spas Portable Spas erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Cal Spas Portable Spas besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Cal Spas Portable Spas verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Cal Spas Portable Spas. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Cal Spas Portable Spas gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
