Benutzeranleitung / Produktwartung 5000 des Produzenten WhisperKool
Zur Seite of 50
EXTREME 5000 / & 8000 / OWNER’ S MANU AL The Coolest Thing In Wine Stor age.
P age 2 EXti 110111 Copyright © 2011. WhisperK OOL. All rights reser ved. This manual, the pr oduc t design, and the design concepts ar e copyrighted by WhisperKOOL, with all rights r eser ved.
P age 1 T ABLE OF C ONTENTS Quick Referenc e G uide U n i t ..................................................... C o n t r o l l e r ................................................ F a n S p e e d & S p e c i c a t i o n s ..................
P age 2 EXti 110111 QUICK REFERENCE GUIDE 5000 - F ront / Side Vie w 5000 / 5000 - Rear / Side V iew MADE IN THE USA Contr oller Bottle Probe Pr obe I nput Grille w/Filt er Contr ol Panel (see page 14.
P age 3 QUICK REFERENCE GUIDE 5000 - F ront / Side Vie w 5000 F ully Duc ted - F ront / Side Vie w R MADE IN THE USA R Rear Contr oller w/R emote Box Bottle Probe Grille w/Filt er Control P anel (see .
P age 4 EXti 110111 QUICK REFERENCE GUIDE 8000 - F ront / Side Vie w 8000 / 8000 - Rear / Side V iew Controller Bottle Probe Pr obe I nput Grille w/Filt er Contr ol Panel (see page 14 for details) Com.
P age 5 QUICK REFERENCE GUIDE 8000 - F ront / Side Vie w 8000 F ully Duc ted - F ront / Side Vie w Compressor Access P anel Contr oller w/R emote Box Bottle Probe Grille w/Filt er Control P anel (see .
P age 6 EXti 110111 E vapor ator and Condenser Fan • • • • ALARM Pre-Chill Dis play Control “ON/OFF” Bu on • T urns the Cooling Unit “ON/OFF” 1 An F rost Compressor Energ y Redu con Hi Bo le T emp History & Scroll Bu on 1 Low Bo le T emp History & Scroll Bu on Push to see the min.
P age 7 F AN SPEED REFERENCE UNIT SPECIFICA TIONS Y our fan speed selection will depend on the amount of heat that needs to be remov ed from the cellar and the ap- plication of the unit (through a wall or fully ducted). F an speed selection will depend on the cellar size , insulation factor , door seal and desired wine temper ature.
P age 8 EXti 110111 INTRODUCTION Cust omer S ervice Thank you f or purchasing a WhisperKOOL Extreme Series cooling unit. W e strive to provide the highest quality prod- ucts and the best possible customer ser vice. If you ha ve any questions about your WhisperK OOL unit, please call us at 1(800) 343-9463.
P age 9 Receiving and Inspecting the Unit • Lift only at the designated hand hold locations on the shipping con tainer or fully suppor t the unit from un- derneath. A shipment may include one or more bo xes containing ac cessories. • Before opening the c ontainer , inspect the pack aging for an y obvious signs of damage or mishandling.
P age 10 EXti 110111 QUICK ST ART GUIDE This guide is meant to serve as a quick ref erence for installation of the WhisperK OOL unit. The remainder of this Owner ’ s Manual will pro vide more detailed information and instructions. Upon receiving the WhisperK OOL unit: 1.
P age 11 The per formance and lif e of your WhisperKOOL unit is c ontingent upon the steps you take in pr eparing the wine cellar . Note: Improperly preparing your enclosur e or incorrectly installing your WhisperKOOL unit may cause unit failure , leak ing of condensation, and other negativ e side eects.
P age 12 EXti 110111 Unobstructed Air ow Unobstructed air flow too and from the unit is critical f or the unit ’ s overall per formance and lif e -span.
P age 13 Ambient T emperature F actor The cooling syst em has the abilit y to cool a wine cellar ecien tly to 55°F as long as the ambient temperature of the area that it is exhausting t o does not exceed 110°F . Therefore , you want to exhaust the unit in a r oom which will not exc eed 110°F .
P age 14 EXti 110111 TEST THE UNIT PRIOR T O INST ALL A TION T o prepare it f or testing before installation in wall: • Unit needs to be in the upright position for 24 hours bef ore star ting.
P age 15 Minimum T ools Needed Locat e the desired installation location (no lower than 18” inches from the ceiling). Using a stud nder , locate the studs on either side of the center point, and mark them with vertical lines.
P age 16 EXti 110111 PREP ARING THE SY STEM FOR INST ALLA TION 5000 / 5000 Applying Insulation T ape Locat e the (4) precut pieces of black foam tape included with the system, two lar ger pieces and two smaller pieces . T o apply , simply peel back the white-paper adhesive cov- ering and place on the mounting bracket.
P age 17 PREP ARING THE SY STEM FOR INST ALLA TION 8000 / 8000 Applying Insulation T ape Locat e the (4) precut pieces of black foam tape included with the system, two lar ger pieces and two smaller pieces . T o apply , simply peel back the white-paper adhesive cov er ing and place on the mounting ange .
P age 18 EXti 110111 Exterior Grille Installation The exterior grille is required on all installa tions where the exhaust side of the unit is exposed to the outside of the dwelling (i.e. r ain and weather). Non-Flush Installa tion Install the system accor ding to the standard through-the-wall procedure .
P age 19 Exterior Grille Installation The exterior grille is required on all installa tions where the exhaust side of the unit is exposed to the outside of the dwelling (i.e. r ain and weather). Non-Flush Installa tion Install the system accor ding to the standard through-the-wall procedure .
P age 20 EXti 110111 THROUGH- THE-W ALL INST ALLA TION Installing the Sy stem Slide the unit from the outside wall int o your wine cellar with the outer ange ush to the wall.
P age 21 DUC TING OVER VIE W Use of Ductwork Use ductwork to connect the unit to the supply and return outlets in the wine cellar . Use only insulated duct- work to minimize c ooling losses, prevent sw eating and reduce noise.
P age 22 EXti 110111 Half Duc t C onguration There ar e a variet y of ways t o duc t this system, please r eview the dierent congurations t o determine a basis for y our par ticular installation. Remember to contact a wine cellar professional if y ou have any questions .
P age 23 F ully Duc ted Attic Moun ted Syst em DUC TING C ONFIGURA TIONS Heat Exhaust Cold A ir Supply- Cellar Condenser Intak e Return Air-Cellar Side It is recommended to use our Insulation Box and Condensa te Pan f or this application.
P age 24 EXti 110111 STEP 1: Remove the lter g r ill from the unit b y unscrewing the screw s that hold it in place. STEP 2: Move the Ducting Adapters int o place STEP 3: Screw the ducting adapters into place using the supplied screws .
P age 25 TM TM The WhisperKOOL Extreme Series can be congur ed with a remote controller syst em. I f you hav e a unit with a re - mote contr oller , please review this section. The contr oller can be installed up to 50 feet away fr om the cooling unit, or up to 300 feet a way with the extended connection wire available fr om WhisperK OOL.
P age 26 EXti 110111 Remote Contr oller Bottle Probe Cooling Unit Below is an illustration of one possible wa y to congure the remote con troller in a wine cellar . Remove the mounting bracket and secur e the bracket to the wall in the desired location.
P age 27 Drain Line All units come with a drain line for additional removal of excessive condensate. It is mandatory to install the drain line with “ T ” fitting. During operation, the cooling unit will strip ex cess water from the air in order to maintain the proper level of humidit y within the cellar .
P age 28 EXti 110111 LIQUID MEASURING THERMOST A T SY STEM The WhisperKOOL Series cooling units c ome equipped with a liquid temperature measuring thermostat system. This system inc or porates the f ollowing advantages: Self-Calibrating P robe The probe c ontains a sensor chip, which actually communicates back and f or th to the thermostat.
P age 29 MUL TI F AN SPEED C ONTROL Designed for wine cellars up t o 1000 and 2000 cubic feet, the Extreme 5000ti/tiR and 8000ti/tiR featur e multi- speed fans with a “high ” setting for maximum per formance in high-t emperature (+110°F) environmen ts and a “low ” setting for super - quiet operation.
P age 30 EXti 110111 Initial Start-Up When power is applied t o the unit, the control will briey display all symbols, and the C ompressor sym- bol will be displayed (if unit is calling f or cooling). There ma y be a br ief delay prior to the evapor ator and condenser fans turning on.
P age 31 ST AND ARD C ONTROLLER FUNC TIONS If your unit is installed through the wall and does not ha ve a remote keypad y ou will have the Standard C ontroller . Button/Symbol Normal F unc tions ON/OFF • The ON/OFF button allow s the customer the convenienc e of tur ning the refrigeration system ON or OFF , from the control panel .
P age 32 EXti 110111 SET 1. Press the “Set ” button once and it will display the Set P oint. After approxima tely 5 sec- onds, the display will r eturn to normal operation and display the Bottle Probe t empera- ture.
P age 33 CPSM Mode Pr ess the “Set ” and the “Down Arrow” buttons simultaneously , for 10-15 seconds , and you will ac cess the “C ustomer Pref erence Selection Mode” (CPSM). The CPSM allows the customer to “F ine T une” the Contr ol Operating System to their applicable choice .
P age 34 EXti 110111 ST AND ARD WIRE SCHEMA TIC COMP NC C NO 3 4 2 7 8 6 1 0 9 10 11 12 ! Max 20A 5 A 16/60 8 A 120V 1 2 3 4 5 6 7 8 8 A Evap. Line Front Receptacle Rear Receptacle Cond Fan Evap F.
P age 35 REMO TE C ONTROLLER FUNCTIONS If your unit has a remote k eypad then you will have the Remote C ontroller . Button Normal F unc tions ON/OFF • The ON/OFF button allow s the customer the convenienc e of tur ning the refrigeration system ON or OFF , from the control panel .
P age 36 EXti 110111 Set 1. Press the “Set ” button once and it will display the Set P oint. After approxima tely 5 sec- onds, the display will r eturn to normal operation and display the Bottle Probe t empera- ture. 2. Pr ess the “Set ” button once and it will display the Set P oint.
P age 37 CPSM Mode Press the “Set” and the “Down Arrow” buttons simultaneously , for 3-5 seconds , and you will access the “ Customer Pr eference Selection Mode” (CPSM). The CPSM allows the customer t o “F ine T une” the Con trol Operating System t o their applicable choice.
P age 38 EXti 110111 REMO TE WIRE SCHEMA TIC COMP NC C NO 3 4 2 7 8 6 1 0 Line Front Receptacle Rear Receptacle Cond Fan Evap Fan Compressor 2 1 3 5 4 6 .
P age 39 MAINTENANCE SCHEDULE Monthly 1. Check lters 2. Check for unusual noise or vibr ation 3. Check the drain line to see if it is abo ve the water line if draining into a vessel . Quar terly 1. Clean F ilters 2. Replace F ilters on duc ted sy stems 3.
P age 40 EXti 110111 TROUBLESHOO TING GUIDE Unit has ice forming on the e vaporator P ossible Cause Evaporator lt er and/or coil are dir ty . There is something blocking the supply and or return air The evaporator fan is not turning on. The unit has not gone through its anti-frost sequence , yet.
P age 41 TROUBLESHOO TING GUIDE Solution Unit should be level in wall to pr event leaking Check drain line to make sure wa ter can ow freely . Disconnect drain and clear out, open access door and check drain for blockage F ix D ra in li ne s o the r e i s a do wn wa rd s lo pe fr o m t he u ni t t o th e dr ai n.
P age 42 EXti 110111 TECHNICAL ASSIST ANCE WhisperKOOL C ustomer Ser vice is available Monday thr ough Friday from 8:00 a.m. t o 4:00 p.m. P acic Time.
P age 43 WHISPERK OOL PRODUC T BASE TERMS WhisperKOOL C orporation (“ WhisperKOOL ”) is in the business of manufactur ing and selling wine cabinets, cooling units and related goods; each such wine cabinet, c ooling unit and related good is referr ed to herein as a “Product” .
P age 44 EXti 110111 (3) This limited warranty does not cov er any Product sold “ AS IS” or “ WITH ALL F AUL TS. ” (4) This limited warranty is valid only in the continental Unit ed States, Alaska and Hawaii. Sales elsewhere (including Puerto Rico) are ex cluded from this warranty .
P age 45 aforemen tioned items in the event that the envir onment becomes unsuitable to maintain a proper storage en vironment. 6. SALES AND USE T A X WhisperKOOL only c ollec ts California sales tax f or orders shipped within the State of California; WhisperK OOL does not collec t sales tax for orders shipped t o other states.
NO TES.
NO TES.
WhisperKOOL 1738 E. Alpine A ve Stockton, CA 95205 1(800) 343-9463 ww w .whisperkool.com.
Ein wichtiger Punkt beim Kauf des Geräts WhisperKool 5000 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie WhisperKool 5000 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für WhisperKool 5000 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von WhisperKool 5000 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über WhisperKool 5000 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon WhisperKool 5000 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von WhisperKool 5000 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit WhisperKool 5000. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei WhisperKool 5000 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
