Benutzeranleitung / Produktwartung Leyden Wood Stove des Produzenten Lopi
Zur Seite of 38
L e y d e n Wood Stove Owner's Manual • Freestanding Stove • Mobile-Home Approved • Alcove Approved • Hearth-Stove Approved Save these instructions for future reference S A FE TY N OTIC E : If thi s appl i anc e is not properly ins tal l ed, a house fi re may re sult.
2 Introduction © Travis Industries 100-01177 4060802 Introduction We welcome you as a new owner of a Leyden wood-burning stove. In purchasing a Leyden you have joined the growing ranks of concerned individuals whose selection of an energy system reflects both a concern for the environment and aesthetics.
Table of Contents 3 © Travis Industries 100-01177 4060802 General Information Introduction & Important Information ...................... 2 Safety Precautions ............................................ 4 Features & Specifications ..........
4 Safety Precautions © Travis Industries 100-01177 4060802 The viewing door must be closed and latched during operation. Never block free airflow through the air vents on this appliance. Gas Gasoline or other flammable liquids must never be used to start the fire or "Freshen Up" the fire.
Safety Precautions 5 © Travis Industries 100-01177 4060802 Mobile Home When installed in a mobile home, this appliance must be bolted to the floor, have outside air, and not be installed in the bedroom (Per H.U.D. requirements). Check with local building officials.
6 Features & Specifications © Travis Industries 100-01177 4060802 Installation Options • Freestanding • Freestanding in an Alcove • Freestanding in a Mobile Home • Freestanding Hearth Stove Features • EPA Phase II Approved • 2.
Stove Installation (for qualified installers only) 7 © Travis Industries 100-01177 4060802 SAFETY NOTICE: P lease r ead t his en t ir e m an u al b efo r e yo u in stall an d u se you r n ew r o o m h eat er . F ailur e to f o llo w in st r u c tio n s m ay r es u lt in p r o p er t y d a m ag e , bo d il y injur y, or even death .
8 Stove Installation (for qualified installers only) © Travis Industries 100-01177 4060802 Floor Protection Requirements • Floor protection must extend 6" to the sides and rear of the stove and 16" to the front of the stove 39.25” wide by 44.
Stove Installation (for qualified installers only) 9 © Travis Industries 100-01177 4060802 Top View - Straight Installation Measure rear and side clearances from the nearest edge of the stove top. Floor Protection 27-1/4” 22-7/8” 16” Min. Measure front clearances from the face of the stove (door opening).
10 Stove Installation (for qualified installers only) © Travis Industries 100-01177 4060802 Bypass Handle Installation See Figure 4 for details on installing the bypass handle. Line up the set screws on the bypass handle with the dimples on the bypass shaft.
Stove Installation (for qualified installers only) 11 © Travis Industries 100-01177 4060802 Chimney Connector Requirements • Chimney connector is required from the flue collar of the stove to the factory-built chimney (see Figure 7 ) or masonry chimney (see Figures 13, 14, and 15).
12 Stove Installation (for qualified installers only) © Travis Industries 100-01177 4060802 Chimney Requirements • DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE SERVING ANOTHER APPLIANCE. • UL 103 HT Chimney must be used from the first ceiling or floor penetration to the chimney cap.
Stove Installation (for qualified installers only) 13 © Travis Industries 100-01177 4060802 Chimney Termination Requirements • Must have an approved cap (to prevent water from entering) • Must no.
14 Stove Installation (for qualified installers only) © Travis Industries 100-01177 4060802 Alcove Installation Requirements Whenever the stove is placed in a location where the ceiling height is less than 8' tall, it is considered an alcove installation.
Stove Installation (for qualified installers only) 15 © Travis Industries 100-01177 4060802 Mobile Home Requirements • Outside air must be installed - see "Outside Air Requirements" on pa.
16 Stove Installation (for qualified installers only) © Travis Industries 100-01177 4060802 Standard Ceiling with a Factory Built Chimney Chimney Cap (See the section "Chimney Termination Requir.
Stove Installation (for qualified installers only) 17 © Travis Industries 100-01177 4060802 Hearth Stove Positive Connection NOTE : Most factory-built chimney manufacturers make stainless steel chimney liners, either flexible or rigid. This provides a wide variety of installation options.
18 Stove Installation (for qualified installers only) © Travis Industries 100-01177 4060802 Interior or Exterior Masonry Chimney NOTE: This type of installation requires a UBC approved masonry connector or other method approved by the NFPA 211 standard.
Operating Your Appliance 19 © Travis Industries 100-01177 4060802 Safety Notice If this appliance is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area.
20 Operating Your Appliance © Travis Industries 100-01177 4060802 Opening the Doors Typically the doors are only opened to start the fire. Use the Loading Lid to re-load the stove. Open the bypass first (this prevents smoke from entering the room). Open the latch.
Operating Your Appliance 21 © Travis Industries 100-01177 4060802 Bypass Operation The bypass controls the flow of smoke inside the heater. When open, smoke goes directly up the flue, creating more draft. When closed, the smoke goes through the combustor, utilizing the secondary combustion system and making the heater more efficient.
22 Operating Your Appliance © Travis Industries 100-01177 4060802 Starting a Fire Since the dawn of time man has debated the best way to start a fire. Some use the boy-scout "tee-pee", some prefer the "tic-tac-toe" stack. Either way, review the hints and warnings below to ensure proper fire starting.
Operating Your Appliance 23 © Travis Industries 100-01177 4060802 Adjusting the Burn Rate Use the air control slider to control the burn rate of the stove. See the illustration below for details. Low Burn (air control closed) High Burn (air control open) Use the air control to change the burn rate.
24 Operating Your Appliance © Travis Industries 100-01177 4060802 Ash Removal ASHES Ashes should be placed in a metal container with a tight fitting lid. The closed container of ashes should be placed on a noncombustible floor or on the ground, away from all combustible materials, pending final disposal.
Operating Your Appliance 25 © Travis Industries 100-01177 4060802 Blower Operation The blower is available to assist the convection chamber in distributing heat to your home. The directions below detail the options you have with the blower and the best method for operation.
26 Operating Your Appliance © Travis Industries 100-01177 4060802 Hints for Burning • Get the appliance hot before adjusting to low burn • Use smaller pieces of wood during start-up and high burn.
Operating Your Appliance 27 © Travis Industries 100-01177 4060802 Troubleshooting Problem Possible Cause Smoke Enters Room During Start-Up • Open the bypass (pg. 21). • Open the air control (pg. 23). • Cold Air Blockage - burn a piece of newspaper to establish a draft.
28 Maintaining Your Appliance © Travis Industries 100-01177 4060802 Failure to properly maintain and inspect your appliance may reduce the performance and life of the appliance, void your warranty, and create a fire hazard. Daily Maintenance (while stove is in use) Remove Ash (if necessary) • Ash removal is not required once it builds up.
Maintaining Your Appliance 29 © Travis Industries 100-01177 4060802 Monthly Maintenance (while appliance is in use) Make sure the appliance has fully cooled prior to conducting service. Door and Glass Inspection The door must form an air-tight seal to the firebox for the stove to work correctly.
30 Maintaining Your Appliance © Travis Industries 100-01177 4060802 Yearly Maintenance Make sure the appliance has fully cooled prior to conducting service. Touch Up Paint Included with the owner's pack of this appliance is a can of Stove-Brite® paint.
Maintaining Your Appliance 31 © Travis Industries 100-01177 4060802 Door Parts 5 9 8 10 4 3 7 2 6 1 ID # Description Qty Part # ID # Description Qty Part # 1 Door, Left 1 2 Door, Right 1 3 Door Gaske.
32 Maintaining Your Appliance © Travis Industries 100-01177 4060802 Firebox Parts 4 2 1 1 7 9 6 3 5 8 7 ID # Description Qty Part # ID # Description Qty Part # 1 Side Brick 2 250-00139 2 Combustion B.
Limited 5 Year Warranty 33 © Travis Industries 100-01177 4060802 To register your TRAVIS INDUSTRIES, INC. 5 Year Warranty, complete the enclosed warranty card and mail it within ten (10) days of the appliance purchase date to: TRAVIS INDUSTRIES, INC.
34 Limited 5 Year Warranty © Travis Industries 100-01177 4060802 CONDITIONS & EXCLUSIONS 1. This new appliance must be installed by a qualified installer. It must be installed, operated, and maintained at all times in accordance with the instructions in the Owner’s Manual.
Listing Information 35 © Travis Industries 100-01177 4060802 Listing Label.
36 Optional Equipment © Travis Industries 100-01177 4060802 Rear Blower Installation (Part # 99000138) The rear blower improves heat transfer by pushing heated air through the convection channel. Operating instructions are described in the section "Blower Operation".
37 Optional Equipment © Travis Industries 100-01177 4060802.
38 Index © Travis Industries 100-01177 4060802 Air Control (Adjusting the Burn Rate) . . . . . . . . . . . . . . . . . . . . . . . 23 Alcove Installation Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 A s h R e m o v a l ....
Ein wichtiger Punkt beim Kauf des Geräts Lopi Leyden Wood Stove (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Lopi Leyden Wood Stove noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Lopi Leyden Wood Stove - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Lopi Leyden Wood Stove reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Lopi Leyden Wood Stove erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Lopi Leyden Wood Stove besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Lopi Leyden Wood Stove verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Lopi Leyden Wood Stove. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Lopi Leyden Wood Stove gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
