Benutzeranleitung / Produktwartung VINT-DVS-U des Produzenten Lennox Hearth
Zur Seite of 32
INST ALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. INST ALLA TEUR: Laissez cette notice avec l'appareil.
2 CO NG RA T UL A TIO N S! When you purchased your new gas stove, you joined the ranks of thousands of individuals whose answer to their home heat- ing needs reflects their concern for aesthetics, efficiency and our environment.
3 IM POR T ANT SA FET Y AN D W A RN ING IN FOR MA TI ON W ARNING Y oung chil dren shoul d be carefully supervised when they are in the same room as the appliance. T od- dlers, young childre n and others may be suscep tible to accidental contact burns.
4 FOR YOUR SAFET Y do not ins tall or operate this appl ianc e witho ut first reading and understanding this manual. Any installation or operation of the appliance deviating from that which is stated in this manual WILL void the warranty and may be hazardous.
5 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A PP OS I T I O N DE S M I SE S E N G AR DE R E L A T I V E S À L A S É C U RI TÉ D ’ U TI LI S A TI O N V o t r e fo y e r a ét é li vr .
6 ORIFICE SIZE/AL TITUDE ADJUSTMENT SMOKE DETECTORS CODES AND APPROV ALS THE GAS STOVE Installation of these appliances are approved for installation in New Y ork City in the US state of New Y ork (MEA#: 138-07-E).
7 PRE-INST ALLA TION Features Installation Options Residential V ented vertical and horizontal Manufactured (mobile) home Natural gas (NG) or propane (LP) Bedrooms Optional wall-mounted or remote thermostat Venting This appli ance can be vent ed wit h Secur e Ve nt™ di rect -v ent pip e by Secu rity Chimneys™*.
8 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Dimensions The gas line screws into the gas valve at the back of the stove 5” in from the right side of the stove and 4-3/16” up from the base of the unit. Preparing Y our Stove For Installation Read all instructions before beginning your installation.
9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Alcove Option 1 Alcove Option 3 Alcove Option 2 Carpet Leg 1-1/2” (38mm) Maximum Corner Installation Clearances to Combustibles Min imum cleara nce s to combus tib le mate ria ls show n here are in inche s (mi llim ete rs) .
10 Firebox Accessories / Parts Cat. No. Description H5861 Log Set H5863 Bag of Embers (volcanic stone) H5864 Bag of Rockwool (glowing embers) H5865 Bag of Steel Wool Log Installation Instructions If l.
11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Side-Insert Installation Follow these steps to install the cast iron inserts or your own custom stone inserts in this appliance: 1. Remove the cast iron top and set it aside. 2. Remove the cast iron upper piece A - see Figure 14 .
12 Vent Installation V enting : This appliance has been tested and listed as a direct-vent heater system by OMNI-T est Laboratories, Portland, Oregon and is rec- ommended for use with Security™ Secure Vent pipe*. Important: • Read all instructions carefully before starting the installation.
13 Vent Parts List Secure Vent direct-vent pipe by Security Chimneys* may be used with this appliance. Please see the lists below to verify the components avail- able from each direct-vent pipe manufacturer . Snorkel terminations are available for applications which may require vertical rise on the building exterior .
14 Snorkel T erminations For installations requiring a vertical rise on the exterior of the building, 14-inch and 36-inch tall snorkel terminations are available.
15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A Flue Opening in the top of the firebox A Restrictor Restrictor Installed Over Flue Opening Figure 23 Figure 25 Figure 24 Flue Restrictors Th.
16 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 8’ Max. Restrictor Position # 4 Restrictor Position # 3 Restrictor Position # 3 Restrictor Position # 2 No Restrictor 18” Section of Pipe Horizontal T erminations The shaded areas in the diagram below show all allowable combinations of vent configurations with horizontal terminations.
17 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Exterior Horizontal Vent T ermination Clearance Requirements V V V V V F C B B A B H M I X V D V A A A V L B J X E V A G *18” 18” B C C C K X * S e e It em D i n th e T e x t B el ow .
18 Gas Line Installation This stove must be connected to the gas line in accordance with local codes and/or the National Fuel Gas Code, ANSI Z223.1 (In Canada, the current CAN/CSA B149.
19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. INST ALLER INSTRUCTIONS - A TT ACHING SAFETY -IN-OPERA TION WARNINGS It is the installers responsibility to ensure these warnings are properly affixed during installation. These warning labels are a critical step in informing consumers of safe operation of this appliance.
20 WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTL Y , A FIRE OR EXPLOSION MA Y RESUL T CAUSING PROPERTY DAMAGE, INJUR Y , OR LOSS OF LIFE. A. This applianc e is equipped with a piezo ignition device to light the pilot. When lighting the pilot, follow these instructions exactly .
21 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNINGS • Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. For assistance or additional infor matio n, consu lt a qualifi ed insta ller , service agency or your gas supplier .
22 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Optional Blower Wiring Diagram FAN SNAP SWITCH - N/O MAIN POWER CORD WIRE (BLACK) GROUND WIRE (GREEN) MAIN POWER CORD WIRE (WHITE) MAIN POWER C.
23 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Millivolt Control Schematic Thermopile ON/OFF Rocker Switch, Thermostat, or Remote Thermostat Piezo Igniter Thermocouple Pilot Gas Line Sparker.
24 CAUTION: Wear gloves and safety glasses for protection while doing required maintenance. Verify proper operation after servicing. S'assurer que l'appareil fonctionne adéquatement une fois l'entretien terminé. Maintenance Checklist: The following should only be performed by a qualified ser vice technician.
25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Door Latch Figure 36 Glass Door Only doors certified with the appliance shall be used. Seules des portes certifiées pour cet appareil doivent être utilisées. CAUTI ON: DO NOT abuse glass door by strikin g or slam ming shut.
26 TROUBLESHOOTING NOTE: When troubleshooting the gas control system, be sure the external gas shut off valve, located at the gas supply inlet is in the “ON” position. IMPORT ANT : Call your gas supplier or plumber for additional help with any gas control problem.
27 REPLACEMENT P ARTS - V IN T - DV S- U / SD VC S Cat. No. Description H6031 Cassette Assembly , NG (if LP , also requires 75190 Conversion Kit) H5936 Burner Assembly H5947 Pilot Assembly NG H2830 Pi.
28 Pa nel K it s (R e q ui r e d) (r ef . Fo rm # 77 52 94 M) Ca t. No . Mo del De scr ip ti o n 75 1 99 VI N T -C P S- B C as t I r on Pa n el Se t /B l ac k , R ev e rs i bl e u H7 4 06 VI N T AG E -P K -B G G a ll o V en ez i an o S t on e P a ne l s Ga s C on ve r s io n Ki t s Ca t.
29 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. IGN 11-0831 Part No./No. Pièce #36224 Rev. B, 02/2011 2011 2012 2013 2014 LENNOX 1 1-0831 FRONT SAFETY / LISTING LABEL - VI NT -DVS -U / S DV .
30 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. LIGHTING LABEL - VI NT -DVS -U / S DV CS IGN 11-0831 Part No./No. Pièce #36224 Rev. B, 02/2011 LENNOX 1 1-0831 BACK.
31 NOTES.
32 Printed in U.S.A. © 2007 Lennox Hearth Products P/N 775227M REV . F 09/2011 Lennox Hearth Products reser ves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.
Ein wichtiger Punkt beim Kauf des Geräts Lennox Hearth VINT-DVS-U (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Lennox Hearth VINT-DVS-U noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Lennox Hearth VINT-DVS-U - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Lennox Hearth VINT-DVS-U reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Lennox Hearth VINT-DVS-U erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Lennox Hearth VINT-DVS-U besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Lennox Hearth VINT-DVS-U verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Lennox Hearth VINT-DVS-U. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Lennox Hearth VINT-DVS-U gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
