Benutzeranleitung / Produktwartung RG02515GNSX des Produzenten Generac
Zur Seite of 60
Owner ’ s Manual For Sp ark-Ignited S t ationary Emergency Generators Residential and Commercial This manual should re main with the unit. This manual must be used in conjunction with the appropriate inst allation manual. * NOT INTENDED FOR USE IN CRITICAL LIFE SUPPOR T APPLICA TIONS.
ii Owner ’s Manual for S tationary Emergency Generators Use this p age to record import ant information about the generator set. For quick and easy re ferenc e, copy the information printed on the Unit Identification Label onto the sample label printed here.
T able of Conten ts Owner ’s Manual for S tationary Emergency Generators iii Section 1 Safety 1.1 Introduction ............ ................................. ................................................. ................ ............ 1 1.2 Safety Information .
T able of Content s iv Owner ’s Manual for S tationary Emergency Generators Section 4 Operation 4.1 Control Panel ...... ........................................................................... ............................ ......... 19 4.2 Auto/Manual/Off .
T able of Conten ts Owner ’s Manual for S tationary Emergency Generators v 5.7 Schedule A Maintenance ............ ............................................................. .............. ............ 3 1 5.7.1 Schedule A Maintenance I tem Locations .
T able of Content s vi Owner ’s Manual for S tationary Emergency Generators (000004) W ARNING California P roposition 65. Engine exhaust and some of its constituents are known to the state of Calif ornia to cause cancer , birth defects, and other reproductive harm.
Owner ’s Manual for S tationary Emergency Generators 1 Section 1 Safety 1.1 — Introduction Thank you for purchasing this st ationary automatic st andby generator set. Every ef fort was made to ensure that the information in this manual was both accurate and co mplete at the time it was released .
Safety 2 Owner ’s Manual for S tationary Emergency Generators 1.2 — Safety Information S tudy these safety rules carefully before operating or servicing th is equipment.
Safety Owner ’s Manual for S tationary Emergency Generators 3 1.4 — Exhaust Hazards • Generator eng ine exhaust cont ains DEADL Y carbon monoxi de, an odorles s, colorless, poison ous gas.
Safety 4 Owner ’s Manual for S tationary Emergency Generators This p age intentionally lef t blank..
Owner ’s Manual for S tationary Emergency Generators 5 Section 2 Specifications 2.1 — Emission Information The U.S. Environmental Protection Agency (EP A) require s that the generator comp ly with exhaust emission st andards.
S pecifications 6 Owner ’s Manual for S tationary Emergency Generators 2.2 — S pecifications Model 22 kW 25 kW 27 kW 30 kW 32 kW 36 kW 38 kW 45 kW 48 kW 60 kW Engine 2.
S pecifications Owner ’s Manual for S tationary Emergency Generators 7 A complete specification sheet is included in the do cumentat ion provided with the unit at the time of purchase. For additional copies, consult your local Indepen dent Authorized Service Dealer .
S pecifications 8 Owner ’s Manual for S tationary Emergency Generators 2.4 — We ather and Maintenance Kit s T o keep the generator running at its peak, the follo wing kits are of fered: • Cold W.
S pecifications Owner ’s Manual for S tationary Emergency Generators 9 2.7 — Reconfiguring the Fuel System While some models are crea ted fuel specific for either Natural gas (NG) or Liq uid Propan e vapor (LPV) and are no t fuel convertible, others are configu red at the factor y for NG , but ar e field conver tible to LPV .
S pecifications 10 Owner ’s Manual for S tationary Emergency Generators Serious injury , including death, or damage will occu r if not configure d properly .
Owner ’s Manual for S tationary Emergency Generators 11 Section 3 Activation and S t artup 3.1 — Orient ation NOTE: The 2.4L (32 kW) unit is depicted in the artwork used in this manual. The location and appeara nce of some component s may vary between engine models.
Activation and S tartup 12 Owner ’s Manual for S tationary Emergency Generators 3.3 — Inst all Battery CAUTION: Always connect t he positive battery cable first. If the posi tive cable should cont act ground with the negative cable inst alled, the result- ing sp arks may cause a ba ttery explosion which could result in serious injury .
Activation and S tartup Owner ’s Manual for S tationary Emergency Generators 13 3.5 — Activate Unit Display Reads: Generator Active is displayed on the LCD screen when the unit is first powered up.
Activation and S tartup 14 Owner ’s Manual for S tationary Emergency Generators 3.6 — S t art and Run Engine 1. Pull up rubber flap covering fuse holder and verify installation of 7.5 amp fuse. See A of Figure 3-5. 2. Move the Main Circuit Breaker switch down to the OFF (Open ) position.
Activation and S tartup Owner ’s Manual for S tationary Emergency Generators 15 3.7 — Operational Checks The following procedures req uire special tools and skills.
Activation and S tartup 16 Owner ’s Manual for S tationary Emergency Generators 9. Allow the engine to warm up for about five min utes. Move the Main Circuit Breake r switch on the generator con- trol panel up to the ON (or closed) position. Generator power volt age is now supplied to the transfer switch.
Activation and S tartup Owner ’s Manual for S tationary Emergency Generators 17 1. V erify that the generator is OFF . A re d LED on the control panel illuminates to confirm that the s ystem is in the OFF mode. 2. Install front cover of the transfer switch.
Activation and S tartup 18 Owner ’s Manual for S tationary Emergency Generators This p age intentionally lef t blank..
Owner ’s Manual for S tationary Emergency Generators 19 Section 4 Operation 4.1 — Control Panel NOTE: The control p a nel is intende d for use by q ualified service personn el only . The control pane l is located behind the vi ewing window at the rear of the unit.
Operation 20 Owner ’s Manual for S tationary Emergency Generators Figure 4-2. Control Panel and LCD Screen 4.3 — Menu Navigation See Figure 4-3. Feature Description System Menus HOME Screen The system returns to the Home screen if the control panel is not used for five minutes.
Operation Owner ’s Manual for S tationary Emergency Generators 21 Navigation ESCAPE Used to abort a routine or back up to the preceding menu. ENTER Used to make a select ion or save an entry .
Operation 22 Owner ’s Manual for S tationary Emergency Generators “Run Log” ESC ENTER ENTER ESC SYSTEM BA TTERY DA TE/TIME SUB MENUS HISTORY EDIT MAINT DEALER Exercise Time Å 14:00 Wednesday Æ.
Operation Owner ’s Manual for S tationary Emergency Generators 23 Figure 4-3. Navigation Menu 4.4 — Alarm/W arning Conditions The owner/operator is alerted to Alar m and/or W arning conditions via the cont rol p anel LCD screen. All Alarm condi- tions cause the gene rator to shut down.
Operation 24 Owner ’s Manual for S tationary Emergency Generators 4.6.2— User Programmable 4.6.2.1—St art-Up D elay Timer A programmable line inte rrupt delay (or S tart-Up Delay) timer is provided. When utility vo ltage fails (falls below 60% of nominal), the start-up delay timer is started.
Operation Owner ’s Manual for S tationary Emergency Generators 25 4.9.1— Automatic Sequence of Operation 4.9.1.1—Utility Failure If the control panel is set to AUTO when the utility power fails, a ten second S tar t-Up Delay timer is started (user pro- grammable).
Operation 26 Owner ’s Manual for S tationary Emergency Generators IMPORT ANT NOTE: Always use the applicable transf er switch owner's manual for actual manua l transfer switch op eration in structions . The information presented here describes a tra nsfer switch, which is not used for three phase applicat ions.
Owner ’s Manual for S tationary Emergency Generators 27 Section 5 Maintenance 5.1 — Component Locations The side of the enclo sure with the vi ewing window is identified as the rear of the generato r set. The right and le ft sides are identified by st anding at the re ar an d looking towards the front of the unit.
Maintenance 28 Owner ’s Manual for S tationary Emergency Generators Figure 5-3. Left Side V iew NOTE: All normal maintenance and service ite ms are easily accessible for cons umer convenience. Wherever possible, touch point s are colored orange to provide for quick and easy recogn ition.
Maintenance Owner ’s Manual for S tationary Emergency Generators 29 5.3 — Service Main tenance Intervals NOTE: Use only Genuine Generac p arts to ensure warr anty coverage. All generator service must be performed by an au thorized service pro vider or a qualified service per son- nel only .
Maintenance 30 Owner ’s Manual for S tationary Emergency Generators 5.4 — Remove From Service T o ensure safety , follow the steps below pr ior to inspection, ma inte nance or service. IMPORT ANT NO TE: If currently experiencing a utility out age, see Subsection 6.
Maintenance Owner ’s Manual for S tationary Emergency Generators 31 5.7 — Schedule A Maintenance NOTE: Perform Schedule A maintenance once each year or af ter 125 hours of service, whichever comes first. NOTE: The 2.4L (32 kW) unit is depicted in the art work used in this manual.
Maintenance 32 Owner ’s Manual for S tationary Emergency Generators 5.7.5— Check Coolant Level and Hoses Do not add coolant when the engine is hot. S team and scalding fluids can cause severe burns. 1. V erify that the coolant level is between t he HOT and COLD marks on the overflow reservoir .
Maintenance Owner ’s Manual for S tationary Emergency Generators 33 7. V erify that the oil level is at or near the FULL mark. Add oil as necessary . See A of Figure 5-7 NOTE: Observe the oil lev el on both sides of the dip stick. The lower of the two readings is the co rrect oil level measurement.
Maintenance 34 Owner ’s Manual for S tationary Emergency Generators 2. Use one wrench to hold hex on hose fitting (to prevent r otation), an d use second wrench to remove drain plug . Hot oil may cause burns. Allow engine to cool befor e draining oil.
Maintenance Owner ’s Manual for S tationary Emergency Generators 35 Figure 5-8. Oil Drain Hose, Fi ll Cap, Dipstick and Filter A B.
Maintenance 36 Owner ’s Manual for S tationary Emergency Generators Oil Fill Cap Oil Fill Cap Oil Fill Cap Oil Fill Cap Oil Fill Cap Oil Filter Oil Filter Oil Filter Oil Filter Oil Filter Air Cleaner Air Cleaner Air Cleaner Air Cleaner Oil Level Dipstick Oil Level Dipstick Oil Level Dipstick Air Cleaner Oil Level Dipstick Oil Level Dipstick 2.
Maintenance Owner ’s Manual for S tationary Emergency Generators 37 Figure 5-9. Engine O il and Air Cleaner Main tenance (All Models) 5.7.9— Check Batter y Condition/Fluid Level 5.7.9.1— Check Con dition and Clean 1. V erify that top of battery is clean a nd dry .
Maintenance 38 Owner ’s Manual for S tationary Emergency Generators Inst allation Always connect the positive bat tery cable first. If the positive cable sh ould cont act ground with the negative cable ins t alled, the resulting sp arks may cause a battery explos ion which could result in seri- ous injury .
Maintenance Owner ’s Manual for S tationary Emergency Generators 39 Figure 5-12. Check Accesso ry/Drive Belt Deflection 5.7.1 1— Rep lace Air Filter Element 1. Remove wing nut, lock washer and flat washer from threade d rod to release air clean er cover .
Maintenance 40 Owner ’s Manual for S tationary Emergency Generators Figure 5-13. Air Cleaner Co ver and Filter Element NOTE: Service kit s are available from Independ ent Authoriz ed Service Dealers. 5.7.12— Final Instructions If only performing Sche dule A maintenance procedures, proceed as follows: 1.
Maintenance Owner ’s Manual for S tationary Emergency Generators 41 5.8 — Schedule B Maintenance NOTE: Perform Schedule B maintenance every two years or af ter 250 hours of s ervice, whichever c omes first. Before proceeding below , first perform all t asks listed under Schedule A Maintenance.
Maintenance 42 Owner ’s Manual for S tationary Emergency Generators 14. Insert funnel into filler neck of radiator . See B of Figure 5-14 15. Slowly pour coolant into filler neck until radiator is full. 16. Install radiator ca p. 17. Press MANUAL on the control panel to start the engine.
Maintenance Owner ’s Manual for S tationary Emergency Generators 43 Figure 5-15. Adjust Spark Plug Gap 5. Check condition of threads in cylinder head and on sp ark plugs. If necessary , soften deposit s with penetrating oil and clean out with a thread chaser .
Maintenance 44 Owner ’s Manual for S tationary Emergency Generators 5.9 — Schedule C Maintenance NOTE: Perform Schedule C maint enance af ter 1000 hours of service. Before proce eding below , first perform all t asks listed under Sch edule A Maintenance and Schedule B Maintenan ce.
Maintenance Owner ’s Manual for S tationary Emergency Generators 45 5.1 1 — Lube Oil Maint ainer System 5.1 1.1— Des cription NOTE: Oil reservoir is empty when shippe d from factory . Fill with clean engine oil to activate the system. The 36 kW , 45 kW , and 60 kW models are equipped with a Lube Oil Maint ainer System.
Maintenance 46 Owner ’s Manual for S tationary Emergency Generators 5.1 1.3— T est Functionality See A of Fi gure 5-17. Mo mentarily press the te st button to c onfirm that th e float is oper ating correctly . Do not hold the tes t button down fo r a prolonged period of t ime or the crankc ase can be over f illed.
Owner ’s Manual for S tationary Emergency Generators 47 Section 6 T roubleshooting 6.1 — Engine T roubleshooting Problem Cause Correction The engine will not crank. Fuse blow n. Replace 7.5 a mp fuse in gene rator con- trol panel. Cor rect short circuit condi- tion if fuse blows again.
T r oubleshoot ing 48 Owner ’s Manual for S tationary Emergency Generators 6.2 — Controller T roubleshooting Active Alarm Problem Solution NOT ACTIV A TED Unit will not start in AUTO with utility loss. Refer to activation sectio n in Owner ’s Manual.
T roubleshooting Owner ’s Manual for S tationary Emergency Generators 49 6.3 — Removal From Servic e During Utility Out ages If, during prolonged utility outages, the us er wishes to remove the unit from serv ice to conserve fuel, reduce run hours, or to perform main tenanc e tasks, then complete the steps listed be low .
T r oubleshoot ing 50 Owner ’s Manual for S tationary Emergency Generators NOTE: On 36 kW , 45 kW , and 60 kW models, close shutoff valve to avoid dr aining the oil supply t ank with the crankcase oil. For more infor mation, see Subsection 5.1 1 —Lube Oil Maintainer System.
T roubleshooting Owner ’s Manual for S tationary Emergency Generators 51 12. Press MANUAL on the control panel to st art the engine. A blue LED illuminates to confirm that the system is in the MANUAL mode . 13. Allow the engine to run until it is reaches normal o perat ing temperature.
T r oubleshoot ing 52 Owner ’s Manual for S tationary Emergency Generators This p age intentionally lef t blank..
This p age intentionally lef t blank..
Part No. 0K8185 Rev . A 02/16/2015 Printed in USA ©2015 Generac Power Systems, Inc. All rights reserved S pecifications a re subject to change wi thout notice. No reproduction allowed in any form without pri or written consent from Generac Power Systems, Inc.
Ein wichtiger Punkt beim Kauf des Geräts Generac RG02515GNSX (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Generac RG02515GNSX noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Generac RG02515GNSX - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Generac RG02515GNSX reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Generac RG02515GNSX erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Generac RG02515GNSX besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Generac RG02515GNSX verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Generac RG02515GNSX. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Generac RG02515GNSX gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
