Benutzeranleitung / Produktwartung ASF-60E des Produzenten Alto-Shaam
Zur Seite of 60
PHONE: 262.
Delivery ...................................... 1 Unpacking .................................... 1 Safety Procedures and Precautions ................. 2 Installation Dimension Drawings, weights & capacities ........ 3-4 Installation Requirements .
Electric Fryer Operation & Care Manual • 1 DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier.
Electric Fryer Operation & Care Manual • 2 INSTALLATION Electric Fryer Operation & Care Manual • 2 INSTALLATION CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored.
Electric Fryer Operation & Care Manual • 3 INSTALLATION Electric Fryer Operation & Care Manual • 3 INSTALLATION ASF-75E SPECIFICATIONS CAPACITY SHORTENING/OIL: 73lb (33 kg).
Electric Fryer Operation & Care Manual • 4 INSTALLATION ASF-60E SPECIFICATIONS 23-3/8 " (592mm) 47-1/2 " (1206mm) 15-3/4 " (400mm) 33-5/8 " (853mm) 44-3/8 " (1127mm) 50-.
Electric Fryer Operation & Care Manual • 5 INSTALLATION NOTE: To avoid equipment damage, remove the Mobile Oil Trolley before moving this appliance with a forklift or pallet lift.
1. It is the responsibility of the installer to verify that this fryer installation is in compliance with the specications listedin this manualand with local code requirements. 2. Hood installation is required. 3. Both cooking and cleaning functions require unobstructed access.
Electric Fryer Operation & Care Manual • 7 INSTALLATION An adequate ventilation system is required for commercial cooking equipment. Information may be obtained by writing tothe National FireProtection Association, BatterymarchPark, Quincy, MA02269.
Electric Fryer Operation & Care Manual • 8 INSTALLATION The fryer must be supplied with a connector that complies with all state and local installation codes. A ny appliance that is not furnished with a power supply cord but that includes a set of casters must be tethered.
Electric Fryer Operation & Care Manual • 9 INSTALLATION An electrical wiring diagram is located in the front access door of the fryer. The fryer must be installed by a qualiedelectrician.
Electric Fryer Operation & Care Manual • 10 INSTALLATION 1. Refer to the nameplate on the FRONT of the fryer. Verify the electrical service power. Voltage and phase must match the nameplate specifications and available electrical service amperage must meet or exceed the specifications listed.
Electric Fryer Operation & Care Manual • 11 OPERATION OIL/SHORTENING REQUIREMENTS TheASF-75E requires 73-pounds (33kg) of oil or shortening in the frypot and the ASF-60E requires 62-pounds (28kg) of oilor shortening .
Electric Fryer Operation & Care Manual • 12 OPERATION Electric Fryer Operation & Care Manual • 12 OPERATION ASF-75E, 120V WITH FILTRATION oil hi - limit reset nozzle kettle selector nozzle.
Electric Fryer Operation & Care Manual • 13 OPERATION Electric Fryer Operation & Care Manual • 13 OPERATION NOTE: Perform an initial Boil-Out to clean and sanitize the fryer before operating. Carbonized deposits along with an accumulation of oil will eventually build-up on the interior of the frypot as well as fryer accessories.
Electric Fryer Operation & Care Manual • 14 OPERATION 8. Turnthe Master Power Switch(located behind the frontaccess door) to the “ON” position and press the CONTROL RESET . 9. To enter Boil Mode, press and hold the P key for 3 seconds.
Electric Fryer Operation & Care Manual • 15 OPERATION NOTE: Perform an initial Boil-Out to clean and sanitize the fryer station before operating.
Electric Fryer Operation & Care Manual • 16 OPERATION THOROUGHLY CLEAN DAILY The cleanliness and appearance of this unit will contribute considerably to operating efficiency and savory, appetizing food. Good equipment kept clean works better and lasts longer.
Electric Fryer Operation & Care Manual • 17 OPERATION Carefulobservation of the nishedfood product will help determineoptimal ltering frequency. Filtering the cooking oil at regular intervals will help ensure food quality.
Electric Fryer Operation & Care Manual • 18 OPERATION FILTER REPLACEMENT 1. With the DRAIN in the “CLOSED” position, pull the trolley from the fryer and disconnect the hose from the fryer.
Electric Fryer Operation & Care Manual • 19 OPERATION FILTER CLEANING & MAINTENANCE NOTE: Make certain to use hand protection when working with hot surfaces. REUSABLE MESH FILTER OPTION: Clean the reusable mesh filter (FI-27014) b y spraying thoroughly with hot water.
Electric Fryer Operation & Care Manual • 20 OPERATION CLEANING & MAINTENANCE OIL DISCARD HOSE OPTION: Theoil discard hose option(HO-27686) is available as an option to assist both the boil-out and ltrationoperation.
Electric Fryer Operation & Care Manual • 21 DELUXE CONTROL OPERATION Electric Fryer Operation & Care Manual • 21 DELUXE CONTROL OPERATION PANEL IDENTIFICATION 1 3 5 6 7 2 4 8 9 1. LED DispLa y 2. H oLD inDi ca t or 3. HEa t inD ica tor 4. MEL t cy cLE inD ica tor 5.
Electric Fryer Operation & Care Manual • 22 DELUXE CONTROL OPERATION Electric Fryer Operation & Care Manual • 22 DELUXE CONTROL OPERATION Start a Cook Cycle Press any product key to start a cook cycle. If the key is programmed, the cooking time will be displayed and will immediately start to count down in minutes and seconds.
Electric Fryer Operation & Care Manual • 23 DELUXE CONTROL OPERATION DELUXE CONTROL OPERATION To Check Product Counts : press and hold the P key for 3 seconds. C OUNT S will be displayed. Press the P ke y. PR OD 1 will be displayed then the number of cooks that were completed on that key .
Electric Fryer Operation & Care Manual • 24 DELUXE CONTROL OPERATION Product Ke y Programming 10 button controllers have a single, dual-purpose display that will alternate information; for example: then ENTER PROGRAMMING MODE. Press and hold the P key for 3 seconds.
DELUXE CONTROL OPERATION T ype in 1 7 2 4 using the product keys. Press the P key. Press the P key . All product key LEDs will light up. PROGRAM A PRODUCT KE Y.
Electric Fryer Operation & Care Manual • 26 DELUXE CONTROL OPERATION Press the P ke y. Press the up arrow ke y. Press the P key . Either press another product key to program and repeat the programming instructions, or continue by pressing the down arrow key .
Electric Fryer Operation & Care Manual • 27 DELUXE CONTROL OPERATION ENTER SYSTEM PRO- GRAMMING MODE. Press and hold the P key for 3 seconds. T ype in 3 2 2 8 using the product keys. Press the P key. Press the down arrow key . Press the P key . SET APPLIANCE MODE.
Electric Fryer Operation & Care Manual • 28 DELUXE CONTROL OPERATION ENTER LIBRARY PRO- GRAMMING MODE. Press and hold the P key for 3 seconds. T ype in 3 2 2 8 using the prod- uct keys. Press the P ke y. Press the down arrow key . Press the down arrow key to select either PRODLIBR OR ALRMLIBR.
Electric Fryer Operation & Care Manual • 29 OPERATION SUGGESTED FRYING TIMES item minutes temperature display 1. Fries ( FROZEN ) 3:30 350°F (177°C) Fries 2. Chicken Nuggets ( FROZEN ) 3:30 350°F (177°C) Nuggets 3. Fish, Breaded ( FROZEN ) 4:30 350°F (177°C) Fish 4.
Electric Fryer Operation & Care Manual • 30 OPERATION SUGGESTED FRYING TIMES ITEM MINUTES TEMPERATURE Eggplant 4:00 340°F (171°C) EggRolls ( froZen ) 5:00 340°F(17.
Electric Fryer Operation & Care Manual • 31 SERVICE SERVICE DANGER DISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING. CAUTION THIS SECTION IS PROVIDED FOR THE ASSISTANCE OF QUALIFIED SERVICE TECHNICIANS ONLY AND IS NOT INTENDED FOR USE BY UNTRAINED OR UNAUTHORIZED SERVICE PERSONNEL .
Electric Fryer Operation & Care Manual • 32 SERVICE PROBLEM CAUSE SOLUTION N o p ow er Circuit b reaker OFF Check and r es et A pplia nce not pl ug ged in Plug in cor d Defective 24V A C transformer Replace transfo rmer Replace con troller N o s ound I noperable speaker Replace con troller Button proble m Fr ozen key U nplug co ntro l ler .
Electric Fryer Operation & Care Manual • 33 SERVICE SERVICE 1. FRYER WILL NOT POWER-UP A. Make certain cord is plugged in and breaker is turned “ o n .” B. Ensure the drain switch is turned to the “ closed ” position. C. Ensure the master switch is turned to the “ o n ” position.
Electric Fryer Operation & Care Manual • 34 ASF-60E SERVICE Electric Fryer Operation & Care Manual • 34 ASF-60E SERVICE ASF-60E WITH AUTOMATIC LIFTS 6 5 7 8 9 10 11 1 2 3 4 380415 ASF-60E .
Electric Fryer Operation & Care Manual • 35 ASF-60E SERVICE Electric Fryer Operation & Care Manual • 35 ASF-60E SERVICE ASF-60E WITH AUTOMATIC LIFTS 1 2 3 4 4 3 2 5 2 3 1 6 SEE NOTE NOTE: 1012370 IS ONLY USED WITH NO LIFT UNITS.
Electric Fryer Operation & Care Manual • 36 ASF-60E SERVICE ASF-60E 5 2 3 4 1 6 5 7 1 2 3 4 8 1 5014288 CONTROL PANEL ASSEMBLY ITEM DESCRIPTION P/N QTY 1 Nut, #8-32 NU-26526 8 2 Gasket, 1/2".
Electric Fryer Operation & Care Manual • 37 ASF-60E SERVICE ASF-60E WITH AUTOMATIC LIFTS 2 3 4 5 6 1 ITEM P/N DESCRIPTION QTY 1 1008420 Guide Column 2 2 1008421 Guide Support 2 3 RD-28118 Rod, L.
Electric Fryer Operation & Care Manual • 38 ASF-60E SERVICE ASF-60E WITH AUTOMATIC LIFTS .
Electric Fryer Operation & Care Manual • 39 ASF-60E SERVICE ASF-60E WITH AUTOMATIC LIFTS .
Electric Fryer Operation & Care Manual • 40 ASF-75E SERVICE Electric Fryer Operation & Care Manual • 40 ASF-75E SERVICE ASF-75E, WITH FILTRATION & LIFTS 6 4 5 1 2 7 3 .
Electric Fryer Operation & Care Manual • 41 ASF-75E SERVICE Electric Fryer Operation & Care Manual • 41 ASF-75E SERVICE ASF-75E, WITH FILTRATION & LIFTS 4 2 3 3 5 6 1 .
Electric Fryer Operation & Care Manual • 42 ASF-75E SERVICE ASF-75E, WITH FILTRATION & LIFTS .
Electric Fryer Operation & Care Manual • 43 ASF-75E SERVICE ASF-75E, WITH FILTRATION & LIFTS 8 6 1 7 1 7 1 0 1 0 1 4 1 3 1 6 4 1 5 3 5 1 5 1 2 9 7 1 1 2 1 6 1 7 17 1 0 1 0 1 .
Electric Fryer Operation & Care Manual • 44 ASF-75E SERVICE ASF-75E, WITH FILTRATION & LIFTS 4 1 3 2 5 5 . A . S . U 0 5 4 0 - 2 5 0 3 5 I W , S L L A F E E N O M O N E M E C N A R E L O T D.
Electric Fryer Operation & Care Manual • 45 ASF-75E SERVICE ASF-75E, WITH FILTRATION & LIFTS 0 2 9 1 3 2 8 1 6 1 2 2 2 3 1 3 6 2 6 2 5 1 4 1 6 2 8 4 2 7 6 3 5 4 2 1 2 5 2 7 1 0 3 6 7 2 9 2 3.
Electric Fryer Operation & Care Manual • 46 ASF-75E SERVICE ASF-75E, NO FILTRATION OR LIFTS 7 4 5 1 2 3 .
Electric Fryer Operation & Care Manual • 47 ASF-75E SERVICE ASF-75E, NO FILTRATION OR LIFTS 4 2 3 3 5 6 1 . A . S . U 0 5 4 0 - 2 5 0 3 5 I W , S L L A F E E N O M O N E M E C N A R E L O T D R .
Electric Fryer Operation & Care Manual • 48 ASF-75E SERVICE ASF-75E, NO FILTRATION OR LIFTS 0 2 9 1 3 2 8 1 6 1 2 2 2 3 1 3 6 2 6 2 5 1 4 1 6 2 8 4 2 7 6 3 5 4 2 1 2 5 2 7 1 0 3 6 7 2 9 2 3 4 8 .
Electric Fryer Operation & Care Manual • 49 ASF-75E SERVICE ASF-75E, NO FILTRATION OR LIFTS 4 4 5 3 1 6 6 2 44 . A . S . U 0 5 4 0 - 2 5 0 3 5 I W , S L L A F E E N O M O N E M E C N A R E L O T.
Electric Fryer Operation & Care Manual • 50 ASF-60E SERVICE Electric Fryer Operation & Care Manual • 50 ASF-60E SERVICE.
Electric Fryer Operation & Care Manual • 51 ASF-60E SERVICE Electric Fryer Operation & Care Manual • 51 ASF-60E SERVICE.
Electric Fryer Operation & Care Manual • 52 ASF-60E SERVICE.
Electric Fryer Operation & Care Manual • 53 ASF-60E SERVICE.
Electric Fryer Operation & Care Manual • 54 ASF-75E SERVICE Electric Fryer Operation & Care Manual • 54 ASF-75E SERVICE.
Electric Fryer Operation & Care Manual • 55 ASF-75E SERVICE Electric Fryer Operation & Care Manual • 55 ASF-75E SERVICE.
Electric Fryer Operation & Care Manual • 56 ASF-75E SERVICE.
Electric Fryer Operation & Care Manual • 57 ASF-75E SERVICE.
TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee.
Ein wichtiger Punkt beim Kauf des Geräts Alto-Shaam ASF-60E (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Alto-Shaam ASF-60E noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Alto-Shaam ASF-60E - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Alto-Shaam ASF-60E reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Alto-Shaam ASF-60E erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Alto-Shaam ASF-60E besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Alto-Shaam ASF-60E verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Alto-Shaam ASF-60E. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Alto-Shaam ASF-60E gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
