Benutzeranleitung / Produktwartung 10061090 des Produzenten Windsor
Zur Seite of 144
Operating Instructions (ENG) MODELS: CSX24 10061090 CSX26SP 10061160 Read these instructions before using the machine iScrub 86317500-A 11/15/08.
MACHINE DATA LOG/OVERVIEW 86317500 CHARIOT SCRUBBE R 11/15/08 2 OVERVIEW The Chariot Scrubber is a battery powered, stand-on, hard floor scrubber intended for commercial use. The appliance applies a cleaning solution o nto a hard floor, scrubs the floor with brushes or pads, and then vacuums the soiled water back into the recovery tank .
TABLE OF CONTENTS 86317500 CHARIOT SCRUBBER 11/15/08 3 Machine Data Log/ Overview . ............................... 2 Table Of Contents ................................................ 3 HOW TO USE THIS MANUAL How To Use This Manual. .................
HOW TO USE THIS MANUAL 86317500 CHARIOT SCRUBBER 11/15/08 1-1 This manual contains the f ollowing sections: - HOW TO USE THIS MANUAL - SAFETY - OPERATIONS - MAINTENANCE - PARTS LIST The HOW TO USE THIS MANUAL section will tell you how to find important information for ordering correct repair parts.
86317500 CHARIOT SCRUBBE R 11/15/08 2-1 IMPORTANT SAFETY INSTRUCTIONS When using an battery powered appliance, basic precaution must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. To reduce the risk of fire, electric sho ck, or injury : Use only indoors.
HAZARD INTENSITY LEVEL 86317500 CHARIOT SCRUBBER 11/15/08 2-2 The following symbols are use d throu ghout this guide as indicated in their descri ptions: HAZARD INTENSITY LEVEL There are three levels of hazard intensit y identified by signal words - WARNING an d CAUTION and FOR SAFETY.
SAFETY LABEL LOCATION 86317500 CHARIOT SCRUBBER 11/15/08 2-3 NOTE: These drawings indicate the location of safet y labels on the machine. If at any time the labels becom e illegible, promptly replace them. PRV NO. 80885 86252520 BATTER Y CAUTI ON PRV NO.
TECHNICAL SPECIFICATIONS 86317500 CHARIOT SC RUBBE R 11/15/08 3-1 ITEM DIMENSION/CAPACITY Nominal power 1800 W Rated Voltage 36 Volts DC Rated Amperage 50 amps Batteries 3 X12 Volt 195-215 AH @ 20 hr. rate Battery Compartment Dimensions 21 in. x 16 in.
TECHNICAL SPECIFICATIONS 86317500 CHARIOT SCRUBBE R 11/15/08 3-2 WIDTH LENGTH HEIGHT ITEM MEASURE Height 50.6 inches (1285 mm) Length 52.5 inches (1330 mm) Width without squeegee 26.
HOW THIS MACHINE WORKS 86317500 CHARIOT SCRUBBE R 11/15/08 3-3 The Chariot® is a battery powered, self-prop elled, hard floor scrubber intended for com mercial use. The appliance applies a cl eaning solution onto a hard floor, scrubs the floor with brushes, and then vacuums the soiled water back into the recovery tank.
COMPONENTS 86317500 CHARIOT SCUBBER 11/15/08 3-4 1. Control Panel-Drive 2. Control Panel-Scrub 3. Control Housing 4. Pedal Platform 5. Rear Cover 6. Tank 7. Recovery Dome 8. Recovery Drain Hose 9. Scrub Deck Aqua-Mizer™ 10. Scrub Deck Skirts/Side Squeegees 11.
DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-5 1 2 3 4 5 6 8 9 7.
DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-6 1. Key Switch 2. Emergency Stop/Brake Switch 3. Directional Control / Drive Reset Switch 4. Throttle Pedal 5. Horn Button 6. Steering Wheel 7. Speed Control 8. Battery Discharge Indicator 9. Hour Meter 1.
DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-7 SLOW FAST 5. HORN BUTT ON The horn is activated by pressing the horn button. 6. STEERING WHEEL The steering wheel turns the front wh eel causing the machine to change dire cti on. 7. SPEED CONTROL Controls the maximum speed of the machine.
DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-8 8. BATTERY CHARGE LEVEL INDICATOR Indicates the charge level of the batterie s. The meter display is divided into 10 vertical bars. Bars illuminated on the fa r right indicate full charge. Bars flashing near the left side indicate the batteries sho u ld be re charged.
SCRUB CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-9 A1 A2 A3 B C 1 1. FUNCTION MODE SWITCH The first two positions are for tran spo r t only. See drive controls section. A1 – Daytime cleaning/light cleaning This mode is used for light cleaning. In this mode the machine will propel at a maximum of medium speed.
SCRUB CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-10 A3 – Heavy scrub level cleaning This mode is used for heavy level cleani ng. In this mode the machine will propel at a maximum of slow speed. The scrub deck will lower to a heavy down pressure. The water will flow at a high rate.
SCRUB CONTRO LS-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 3-11 1 2 1. Squeegee Deflection Adjustment Knobs 2. Squeegee Pitch Adjustment Rod.
SCRUB CONTRO LS-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 3-12 1. SQUEEGEE DEFLECTION ADJUSTMENT KNOBS (DISK SCRU BBE R) Adjusts the deflection along the entire length of the squeegee. To increase squeegee blad e deflectio n, turn the two knobs at the ends of the squeeg ee counterclock wis e.
MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3 - 1 3 PRE-RUN MACHINE INSPECTION Do a pre-run inspection to find possi ble problems that could cause poor perf ormance or lost time from breakdown. Follow the same pro cedure each time to avoid missing steps.
MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-14 FILLING SOLUTION TANK FOR SAFETY: Before le av ing or servicing machine; stop on level surfac e, turn off machine and remove key.
MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-15 TO BEGIN SCRUBBI NG When operating the machine around people, pay close attention for unexpecte d movement. Use extra caution around children. Flammable liquids and/or reactive metals can cause explosions or fire! Do not pick up.
MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-16 TO STOP SCRUBBING 1. Rotate the function knob to either transport position. The brush mo tors will stop and the scrub deck will rise to the park position. After 10 seconds the squeeg ee will raise, and 10 seconds later the vacuum motor will turn off.
MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-17 TANK DOME RECOVERY DRAIN HOSE SOLUTION DRAIN HOSE RECOVERY EMPTYING AND CLEANING TAN KS 1. Park the machine next to a floor drain. Drain hoses are at the front of the machine. 2. Turn the machine power off.
NOTES: 86317500 CHARIOT SCRUBBER 11/15/08 3-18.
MAINTENANCE 86317500 CHARIOT SCRUBBER 11/15/08 4-1 SERVICE SCHEDULE MAINTENANCE BEFORE EACH WORK PERIOD AFTER EACH WORK PERIOD 50 HRS 100 HRS 200 HRS Check water level of batteries after charging; add distilled water if necessary. (Wet cell only) * Check that dome and cover se al tightly.
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBE R 11/15/08 4-2 1 2 3 4 5 6 1. Rear Cover Retainer Knob 2. Rear Cover 3. Battery Connector-Machine 4. Batteries 5.
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBE R 11/15/08 4-3 BATTERIES (WET CELL ONLY) The batteries provide the power to ope rate the machine. The batteries require regul ar maintenance to keep them operating at peak efficiency.
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-4 CHECKING BATTERY SPECIFIC GRAVITY Use a hydrometer to chec k the battery spe cific gravity. CHECKING GRAVITY A. Hydrometer B. Battery NOTE: Do not take readings im mediately after adding distilled water, if the water and acid are not thoroughly mixed, the readi ng may not be accurate.
MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-5 5. Replace the battery caps, and leave them in place while charging. 6. Unplug the battery connector from the machine. FOR SAFETY: When charging, conn ect the charger to the batteries before conne cting the charger to the AC wall outlet.
MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 4-6 1 2 3 4 5 6 1. Squeegee 2. Squeegee Deflection Adjustment Knobs 3. Squeegee Level Indicator 4.
MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 4-7 SQUEEGEE BLADES The front squeegee blade allows solution to pass through channels in the blade into the squee gee assembly while maintaining vacuum to provide lift. The front blade has four wear surfaces and can be rotated for extended life.
MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 4-8 TO ADJUST SQUEEGEE PITCH 1. Choose a smooth, level surface. Turn “ON” the key switch. Lower the squeege e and drive forward at least 2 feet (60cm.). 2. With the squeegee down, stop the machine.
MAINTENANCE-SCRUB BRUSHES 86317500 CHARIOT SCRUBBE R 11/15/08 4-9 SCRUB BRUSHES There are four different types of brushes available to cover applications from cle aning heavily soiled floors to polishing. A pad driver is also available to take advantage of the many cleaning pads on the market.
MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBE R 11/15/08 4-10 1 2 3 4 6 5 1. Scrub deck Aqua-Mizer™ 2. Aqua-Mizer™ retainer knob 3. Scrub deck skirt 4.
MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBE R 11/15/08 4-11 Do not use a pressure washer to clean around the brush motors. Use tap pressure only. TO REPLACE SCRUB BRUS H MOTORS 1. With the scrub deck in the raised position, disconnect brush motor wiring co nnector from harness.
MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBER 11/15/08 4-12 ACTUATOR SCRUB DECK REMOVAL/REPLACEMENT FOR SAFETY: Before leaving or servicing machine, stop on a level surface. Turn off machine. 1. Remove the two screws that secure actuator spring plate and pull actuat or ba rrel from stud on actuator spring bracket.
MAINTENANCE-CIRCUIT PROTECTION 86317500 CHARIOT SCRUBBER 11/15/08 4-13 1 1. CIRCUIT BREAKERS Circuit breakers interrupt the flow of power in the event of an electrical overload. When a circuit breaker is tripped, reset it by pressing th e exposed button.
MAINTENANCE-SOLUTION ST RAINER & PUMP-DISK 86317500 CHARIOT SCRUBBER 11/15/08 4-14 3 4 5 1 6 2 1. Solution Strainer-Coarse 2. Solution Strainer-Fine 3.
MAINTENANCE-SOLUTION STRA INER & PUMP-CYLINDRICAL 86317500 CHARIOT SCRUBBE R 11/15/08 4-15 1 2 3 4 5 6 1. Solution Strainer-Coarse 2. Solution Strainer-Fine 3.
MAINTENANCE-SOLUTION STRAINER & PUMP 86317500 CHARIOT SCRUBBER 11/15/08 4-16 1. SOLUTION STRAINER-COARSE Located in bottom of tank. The coarse strainer protects the finer strainer from larg e deb ris. If the fine strainer is clean and the pump a nd solenoid valve are not working, then check the coarse strainer for debris.
MAINTENANCE-VACUUM & FLOAT SHUT-OFF 86317500 CHARIOT SCRUBBE R 11/15/08 4-17 1 2 1. Recovery tank float shut-off 2. Vacuum motor.
MAINTENANCE-VACUUM & FLOAT SHUT-OFF 86317500 CHARIOT SCRUBBE R 11/15/08 4-18 RECOVERY TANK FLOAT S HUT- OFF When water is no longer being vacuum ed from the floor and the vacuum fan is operating, the ball float has engaged. The vacuum mo tor will not vacuum water with recovery tank full.
MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBE R 11/15/08 4-19 1 2 1. Drive motor 2. Parking brake.
MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBE R 11/15/08 4-20 ELECTRIC PARKING BRAKE ENGA GE MEN T FOR SAFETY: Before leaving or servicing machine, stop on a level surface, turn off machine and remove key. Electric Brake Engagement This machine is equipped with an electric parking brake.
MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBE R 11/15/08 4-21 DRIVE MOTOR CARBON B RUSH REPLACEMENT Do not use a pressure washer to clean around the motors. Use tap pressure only . FOR SAFETY: Before leaving or servicing machine, stop on a level surface, turn off machine and remove key.
MAINTENANCE-BAG REPLACEMENT 86317500 CHARIOT SCRUBBER 11/15/08 4-22 REMOVING OR REPLACING BAG 1. Disconnect batteries a nd make sure parking brake is not overridden. 2. Remove Dome and set aside. 3. Drain all solution from both side s of the bag and rinse well.
MAINTENANCE-BAG TRANSPORTING 86317500 CHARIOT SCRUBBER 11/15/08 4-23 TIE DOW N POINTS PUSHING MACHINE The machine may be pushed for short distan ces at speeds not to exceed 5 mph. Be careful to avoid damaging machine. The machi ne may be pushed by hand from the rear.
MAINTENANCE-TROUBLESHOOTING 86317500 CHARIOT SCRUBBE R 11/15/08 4-24 PROBLEM CAUSE SOLUTION Battery disconnected Check all battery cable connections Emergency shut-off activated Reset Battery cables c.
MACHINE TROUBLESHOOTING 86307500 CHARIOT SCRUBBE R 11/15/08 4-25 PROBLEM CAU SE SOLUTION Faulty vacuum circuit or switch Check wires & connections Vacuum motor does not run, or runs slowly Worn va.
MACHINE TROUBLESHOOTING- CONTROLLER FAULT CODES 86317500 CHARIOT SC RUBBE R 11/15/08 4-26 ERRO R CODE DELUXE PROBLEM SOLUTION LOW BATTERY VOL TAGE THE BATTERY NEEDS CHARGI NG OR THE RE IS A BAD CONNEC.
NOTES: 86317500 CHARIOT SC RUBBE R 11/15/08 4-27.
86317500 CHARIOT SCRUBBER 11/15/08 PARTS.
BUMPER 86317500 CHARIOT SCRUBBER 11/15/08 5-1 1 2 3 4 5 6 7 8 9 10 1 4.
BUMPER 86317500 CHARIOT SCRUBBER 11/15/08 5-2 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86270830 57023 4 NUT, 5/16-18 HEX NYLOCK SS 2 86197040 57264 4 NUT, 5/16-18 HEX ACORN 3 86276.
CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-3 2 3 4 6 7 8 10 12 13 14 15 16 17 18 19A 20 21 23 25 26 9 CONTROLLER SUPPLED WITH 11 27 22 5 HARNESS SUPPLED WITH 1 28 19B 30 29 10 24.
CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-4 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86315470 1 METER, HOUR ICD 2 86005810 57245 2 NUT, 1/4-20 HEX NYLOCK SS 3 86271840 57285 3 NUT, 5/16-18 HEX NYLOCK THN SS 4 86271910 57295 1 NUT, 5/16-18 FLEXLOCK 5 86313900 - 2 RELAY, 5A, 24V, 4PDT 6 86273820 70019 2 SCR, 1/4-20 X 1.
CONTROL PANEL HOUSING 86317500 CHARIOT SCRUBBER 11/15/08 5-5 5 10 9 8 2 3 3 6 1 11 4 7.
CONTROL PANEL HOUSING 86317500 CHARIOT SCRUBBER 11/15/08 5-6 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86005810 57245 4 NUT, 1/4-20 HEX NYLOCK SS 2 86290540 - 6 SCR, 10-32 X 1/2 TORX SS BLK NP 3 86277480 70850 6 SCR, 5/16-18 X1/2 PTHMS SS 4 86317890 - 1 BRKT, LEFT CONSOLE MOUNT 5 86237900 35278 3 GASKET, .
DECAL 86317500 CHARIOT SCRUBBER 11/15/08 5-7 1 2 3 5 4 6.
DECAL 86317500 CHARIOT SCRUBBER 11/15/08 5-8 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1A 86318570 - 1 LABEL, CHAR, ISCURB 24, LEFT 1B 86318590 - 1 LABEL, CHA R, ISCRUB 26C, LEFT 2A .
FRAME-LOWER 86317500 CHARIOT SCRUBBER 11/15/08 5-9 15 12 19 21 13 11 3 8 5 17 16A 20 18 7 2 6 1 14 9 4 2 2 2 2 2 3 11 5 2 10 12 15 5 10 16B 22.
FRAME - LOWER 86317500 CHARIOT SCRUBBER 11/15/08 5-10 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86091420 05251 1 AXLE, REAR, WELDMENT 2 86270830 57023 24 NUT, 5/16-18 HEX NYLOCK SS .
FRAME-UPPER 86317500 CHARIOT SCRUBBER 11/15/08 5-11 2 3 4 5 6 7 3 2 2 2 2 1.
FRAME-UPPER 86317500 CHARIOT SCRUBBER 11/15/08 5-12 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86074160 270101 1 BRKT, SIDE CHANNEL R 2 86270830 57023 10 NUT, 5-16 -18 HEX NYLOCK SS.
PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-13 1 2 3 4 5 7 8 9 10 12 13 14 15 16 18 19 21 22 25 26 27 28 24 23 17 6 11 20 11 15 22.
PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-14 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86233170 20054 2 CLAMP, 3/8 NYLON UL/C SA 2 86264920 27049 1 CABLE TIE, .
PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-15 8 3 9 12 5 1 10 7 8 6 4 14 11 2 13 15 6 5.
PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-16 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86008680 80607 1 COTTER, 1/2” RING 2 86274690 70258 2 SCR, 5/16-18 X 1.5 HHCS GR5PLT 3 86264920 27049 3 CABLE TIE, 7” UL/CSA 4 86231070 730328 2 BUMPER, 1 X 1.
REAR COVER 86317500 CHARIOT SCRUBBER 11/15/08 5-17 13 1 2 3 8 9 10 7 5 6 9 11 12 14 4 16 3 2 15.
REAR COVER 86317500 CHARIOT SCRUBBER 11/15/08 5-18 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276780 70728 3 SCR, 5/16-18 X 3/4 HHCS SS 2 86279130 87083 5 WASHER, 5/16 SPLIT LOCK .
SCRUB BRUSH/PAD DRIVER-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-19 8 4 9 6 5 7 2D 5 3 2C 2A 2B 7 5 8 4 9 6 1.
SCRUB BRUSH/PAD DRIVER-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-20 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86000170 02400 2 PAD DRIVER, 12” SD 2A 86000180 02401 2 BRUSH, 12”.
SCRUB BRUSH/PAD-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-21.
SCRUB BRUSH/PAD-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-22 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 41150040 - 1 WASHER CLOSURE 2 74010050 - 1 BALL BEARING 6302-2RS-DIN6 .
SCRUB DECK – DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-23 18 17 14 15 16 12 13 11 10 8 9 7 6 5 4 3 2 1 8 8 19 19 20 20 FROM PUMP.
SCRUB DECK-DISK 86317500 CHARIOT SCRUBBE R 11/15/08 5-24 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86281100 39274 1 HOSE, 1/2ID WIRE BOUND X 8” 2 86003580 34327 1 FITTING, 1/2”X3/8”X3/8” RED 3 86005490 53808 2 MOTOR ASM, 36VDC300RPM GEAR - 86216200 14739 - BRUSH SET MOTOR 53808 4 86004810 48040 2 KEY, 1/4 SQ X 1.
SCRUB DECK-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-25.
SCRUB DECK-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-26 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 50448660 - 2 RETAINER PLATE TRANSMISSION 2 73060310 - 10 SCREW M 6X16-A2-70.
SCRUB DECK MOUNTING-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-27 1 2 3 4 5 6 7 8 9.
SCRUB DECK MOUNTING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-28 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86315230 - 1 PIN, BALL LOCK 2 86274660 70255 2 SCR, 3/8-16 X 1.5 HHCS GR5 PLT 3 86224370 730335 2 SPACER, 1 OD X .391 ID X .
SCRUB DECK LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-29 20 4 29 7 1 SEE DETAI L 'A' 16 16 8 13 2 9 6 DETAIL 'A' 20 24 25 26 23 22 21 19 21 22 11 12 3 19 18 14 19 15 16 5 10 17.
SCRUB DECK LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-30 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276920 70755 2 SCR, 3/8-16 X 1 HHCS SS NP 2 86008810 80697 2 BALL JOIN T AS.
SCRUB DECK ACTUATOR-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-31 26 17 26 17 16 19 18 23 17 9 1 3 5 6 15 24 27 8 17 2 18 21 22 4 7 28 17 18 16 19 18 23 17 25 14 28 28 1 2 20 12 27 13 11 21 10.
SCRUB DECK ACTUATOR-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-32 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86317340 - 3 SPACER, .
SCRUB DECK SKIRTS-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-33 7 7 20 19 18 22 17 16 15 14 13 9 10 11 12 5 21 5 8 6 5 4 3 2 1 24 23.
SCRUB DECK SKIRTS-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-34 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86270830 57023 4 NUT, 5/16-18 HEX NYLO CK SS 2 86070960 140773 2 BRKT, SKIRT STOP, SCRUBDECK 3 86276070 70593 4 SCR, 5/16-18 X 3/4 CARRI AGE SS 4 86228900 09138 2 BEARING FL ANGED, .
SCRUB DECK AQUA-MIZER™ 86317500 CHARIOT SCRUBBER 11/15/08 5-35 2 8 7 6 3 4 9 9 10 12 3 1 16 15 14 13 17 18 11B 11A 5A 5B.
SCRUB DECK AQUA-MIZER™ 86317500 CHARIOT SCRUBBER 11/15/08 5-36 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86270830 57023 4 NUT, 5/16-18 HEX NYLOCK SS 2 86277050 70782 2 SCR, 5/16-.
SOLUTION-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-37 5 20 18 20 13 14 4 16 15 17 5 SOLENO ID TO TANK TO 7 26 10 5 8 9 34 19 22 24 5 28 11 21 25 6 12 27 28 30 32 29 2 33 31 3 1 23 5.
SOLUTION-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-38 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86248010 57312 1 NUT, 8/32 ACORN CAP, PLATED 2 86226950 40109 1 1” HOSE BARB X 3/4” GHT NYLON 3 86073960 22104 1 CAP, 3/4” GHT W/.
SOLUTION-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-39 36 35 34 SOLENOID TO 7 23 5 22 24 5 28 21 25 6 28 1 18 5 20 5 16 15 14 3 17 2 TANK TO 10 5 8 33 19 11 12 30 32 29 26 31 27 4 9 13 37 38.
SOLUTION-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-40 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. NOTES: 1 86270830 5702 3 2 NUT, 5/16-18 HEX NYLOCK SS 2 86001530 4003 9 1 HOSE BARB, 1/2 MP.
SQUEEGEE-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-41 11 5 11 5 37 2 3 10 7 8 9 35 36 17 16 15 14 15 13 12 9 8 7 6 5 4 1 38 34 33 27A 32 31 30 29 28 25 18 19A 20 21 22 23 24 26 27B 19B 6 40 39.
SQUEEGEE-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-42 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86004890 48095 2 KNOB, ALUM 3/8-16 NYLOCK NUT SS 2 86070920 140759 2 BRKT, SQG WHEEL 3 86006270 66276 2 PIN, CLEVIS 5/16 X 1.63 PLTD 4 86007780 73576 2 SPRING, COMP .
SQUEEGEE-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-43.
SQUEEGEE-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-44 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 73120040 - 2 WASHER 8-00HV-A3E ISO 7090 2 63212110 - 2 STAR GRIP VA 3 5094231.
SQUEEGEE LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-45 14 7 6 10 10 16 13 10 3 20 8 2 12 11 10 9 2 5 1 15 25 15 16 26 27 21 17 16 4 16 17 22 13 20 19 18 17 13 13 13 23 24.
SQUEEGEE LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-46 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86068190 140793 1 BRACKET, ACTUATOR MOUNT 2 86273820 70019 1 SCR, 1/4-20 X 1.
SQUEEGEE LIFT- CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-47.
SQUEEGEE LIFT- CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-48 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86316550 - 1 ACTUATOR, 36VDC, 4.5" STROKE 2 86315270 - 1 BRKT ASSY, ACTUATOR MOUNT 3 86315250 - 1 YOKE, CABLE 4 86315000 - 1 SQUEEGEE MOUNT ASSY 5 86314820 - 1 CABLE ASSY, SQUEEGEE 6 86273740 70010 1 SCR, 1/4-20 X 1.
SQUEEGEE SWING 86317500 CHARIOT SCRUBBER 11/15/08 5-49 1 24 23 22 21 20 3 6 19 18 16 15 14 13 17 11 6 9 10 8 6 7 7 6 5 4 25 2 1 6 12.
SQUEEGEE SWING 86317500 CHARIOT SCRUBBER 11/15/08 5-50 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276690 70715 7 SCR, 5/16-18 X 1.
STEERING 86317500 CHARIOT SCRUBBER 11/15/08 5-51 28 14 22 20 19 19 15 24 13 11 9 6 1 4 5 3 2 27 26 25 16 30 23 21 18 12 10 8 17 29 7.
STEERING 86317500 CHARIOT SCRUBBER 11/15/08 5-52 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86271610 57228 1 NUT, 5/8-16 HEX NYLOCK THN 2 86234810 27945 1 COVER, STEERING WHEEL 3 86259610 730117 1 WHEEL, STEERING 40 SPLINE HUB INCLUDES 27945 4 86224050 730318 1 SHAFT, UPPER STEERING 5 86228790 09111 1 BEARING, FLAN GE .
TANK 86317500 CHARIOT SCRUBBER 11/15/08 5-53.
TANK 86317500 CHARIOT SCRUBBER 11/15/08 5-54 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86313100 - 1 DOME, TANK, 20 X 21 2 86310190 - 1 BASKET, STRAINER, DOME 3 86014530 5 SCR, KA50.
VACUUM 86317500 CHARIOT SCRUBBER 11/15/08 5-55 1 2 3 4 5 6 7 8 9 7 11 10.
VACUUM 86317500 CHARIOT SCRUBBER 11/15/08 5-56 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86314790 - 3 ISOLATOR, RUBBER, 1/4-20 UNC M 2 86314780 - 1 PLATE, VAC MOTOR 3 86012210 - 1 VAC MOTOR, 36VDC 2ST TD 4 86279630 87212 1 WASHER, .
WHEEL-FRONT DRIVE 86317500 CHARIOT SCRUBBER 11/15/08 5-57 1 2 17B 6 3 7 11 15 14 10 9 13 4 16 12 17A 8 18 19 20 21 22 23 24 25 26 27 28 29 30 5 19.
WHEEL-FRONT DRIVE 86317500 CHARIOT SCRUBBER 11/15/08 5-58 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86275190 70377 4 SCR, 3/8-16 X 1.25 HHCS SS 2 86010790 87163 4 WASHER, 3/8 SPLIT LOCK PLTD 3 86002830 27196 1 CABLE TIE, .375 X 24.
WHEEL-REAR 86317500 CHARIOT SCRUBBER 11/15/08 5-59 1B 1A 2 3.
WHEEL-REAR 86317500 CHARIOT SCRUBBER 11/15/08 5-60 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1A 86011110 89261 2 WHEEL, 10X2.5X.787ID BEARINGS 1B 86259930 89274 - WHEEL, 10X2.5, W/BEARINGS, GRY OPTIONAL 2 86008710 80623 2 RING, ¾” EXT SNAP H-D 3 86232130 17309 2 CAP, 2.
WIRING-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 5-61 17 18 19 5 7A 1A 4 3 2 6A 8 10 9 11 12 22 13 14 16 15 20A 20B 24 23 20C 1B 6B 7B 26 25.
WIRING-BATTERIES 86317500 CHARIOT SCRUBBER 11/ 15/08 5-62 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1A 86260200 80872 2 WIRE, 4X14.5BK 3/8RINGX3/8RING 1B 86002510 23125 2 CABLE ASM, BAT. JUMPER X 15” EURO 2 86008920 80889 6 BOOT, RUBBER TERM.
WIRING-COMPONENTS 86317500 CHARIOT SCRUBBER 11/15/08 5-63 1 2 3 4 5 6 6.
WIRING-COMPONENTS 86317500 CHARIOT SCRUBBER 11/15/08 5-64 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86008920 80889 2 BOOT, RUBBER TERM. ISOLATOR 2 86270830 57023 2 NUT, 5/16-18 HEX NYLOCK SS 3 86229770 140805 1 BLOCK, SHUNT MOUNT 4 86273980 70066 2 SCR, 10-32 X 3/4 PPHMS 5 86238500 81427 1 GROMMET, 1.
WIRING-CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-65 65-WHT 67-GRN 63-BRN 37-WHT 61-WHT 32-GR Y 19-PUR 66-YEL 31-BLK 38-YEL 62-WH T K2 K1 72-BRN 73-BLU 64-BLU 7 C 1 PIN 6 K1-PIN 6 K2 PIN 8 K1-.
WIRING-CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-66 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86313700 - 1 HARNESS, PANEL 2 STAGE 2 86010860 880353 1 WIRE, 4X20 BK CTERM C.
WIRING-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-67 KSI-18 AUXsupplyPIN 1 -TO AUX4 / / OPTIONAL -FLASHER OPTIONAL -REAR FLASHER -FRONT FLASH ER -FLASHER UNIT -FLASHER GND -FLASHER POWER 54/ORG 52/YE L 41/BRN 43/BRN 45/BRN 61/WHT 55/VIO 53/GRN 48/BRN 51/WH T 42/BR N 47/BR N 46/BRN 60/WHT 72/BRN 63/BRN 19/VIO -ESTOP -K1 -K2 -K1 -K2 -LED2 -LED1 -K1.
WIRING-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-68 LED B+ INHIBIT OPTIONAL -10K -HM -BRAKE/SW ROTARY -X11 -F1.6A -X17 -HORN/ SW -X14 -K1 -X13 -HORN -ESTOP -KEY -R1/5KPOT -K2 -K1 -X6 -X12 -X5 -X3 -X2 .
WIRING-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-69 / / M -SQUEGE E TRACTION/SOLENOID -WATER -X14 -X12 -18A -18A M -BRUSHR M -BRUSHL -BRAKE M -TRACT ION M -VACUUM B+ B- 24V FOR RELAYS M -SOLUT ION M -.
WIRING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-70 KSI-18 AUXsupplyPIN1 -TO AUX4 / / OPTION AL -FLASHER OPTIONAL -REAR FLAS HER -FRONT FLASHE R -FLASHER UNIT -FLASHER GN D -FLASHER PO WER -ESTOP -K1 -K2 -K1 -K2 -LED2 -LED1 -K1. -REV(K2) -FWRSW -KSI -K2 -K1 -K2.
WIRING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-71 LED B+ INHIBIT OPTIONAL 38/YEL 67/GR N -10K -HM -BRAKE/SW ROTARY -X11 -F1.6A -X17 -HORN/SW -X14 -K1 -X13 -HORN -ESTOP -KEY -R1/5KP OT -K2 -K1.
WIRING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-72 / / M -SQUEGEE -WATER -X14 -X12 -18A -18A M -BRUSHR M -BRUSHL -BRAKE M -TRACTION M -VACUUM B+ B- 24V FOR RE LAYS M -SOLUTION M -DECK -X2 -X1 .
WIRING-DRIVE MOTOR 86317500 CHARIOT SCRUBBER 11/15/08 5-73 1 RED BLK 2 BLK 1 WHT BLK WHT 1 WHT 2 BLK 2 BLK CONTROL PANEL HARNESS.
WIRING-DRIVE MOTOR 86317500 CHARIOT SCRUBBER 11/15/08 5-74 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86239120 41522 1 HARNESS, CHARIOT PROPEL.
WIRING-MAIN HARNESS 86317500 CHARIOT SCRUBBER 11/15/08 5-75 1 DIAGRAM B DIAGRAM C DIAGRAM D BRUSH RIGHT MOTOR MOTOR BRUSH LEFT SQUEEGEE L IFT ACTUATOR VAC MOTOR ACTUATOR SCRUB LIF T SOLENOID VALVE DRI.
WIRING-MAIN HARNESS 86317500 CHARIOT SCRUBBER 11/15/08 5-76 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86313710 - 1 HARNESS, MAIN 2 86318640 - 1 HARNESS, PUMP JUMPER CYL ONLY 3 8631.
WIRING-PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-77 8 BLU 9 RED A 5 GRN 7 BRN 6 ORG DIAGRAM A.
WIRING-PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-78 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86315100 - 1 HARNESS, PEDAL.
HOSE DIAGRAM-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-79 86282190 (13") PRV 395 41 PRV 39540 SCRUB DECK 86281100 (8") 86281310 (8") 86281310 (8") PRV 39326 SOLENOID PUMP VALVE DRA.
HOSE DIAGRAM-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-80 63908920 QUICK DISCONNECT SOLENOID VALVE 86315510 TANK SHUT-OF F PRV 39541 86281950 (32) PRV 39734 86282360 (28") VALVE DRAIN HOSE.
SUGGESTED SPARE PARTS 86317500 CHARIOT SCRUBBER 11/15/08 5-81 PART NO. PRV NO. DESCRIPTION SERIAL NO. FROM NOTES 86316160 - BREAKER, 18A, 250VAC, 32VDC 86008900 80845 BOOT, 7/16 CIRCUIT BREAKER 86004440 39717 CAP DRAIN HOSE 86199840 090-12A FLOAT, SHUT OFF 86317770 - GASKET, DOME EDGE 86305960 - HOSE ASM.
OPTIONS.
BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-1 3 3 15 16 3 3 8 3 3 3 3 3 5 5 5 9 24 8 6 30 29 28 27 26 25 2 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1.
BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-2 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86006930 70514 2 SCR, 5/16-18 X 1.
BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-3 11 13 14 15 6 3 10 12 9 17 3 3 10 10 6 6 8 5 7 7 5 4 3 2 1 10 3 16.
BATTERY CART - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-4 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86078330 66478 1 PEDAL, BATTERY CART 2 86276070 70593 2 SCR, 5/16-18 X 3/4 CARRIAGE SS 3 86270830 57023 12 NUT, 5/16-18 HEX NYLOCK SS 4 86087800 730307 2 STIFFENER, PEDAL, BATTERY CART 5 86228840 09124 4 BEARING, FLAN GED .
SEAT - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-5 2 14 13 12 11 10 9 7 8 6 5 4 3 1 15 17 16 18 19 22 21 20 23 24.
SEAT - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-6 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86248390 730324 1 PAD, REAR REST 2 86082640 629995 1 PLATE, SEAT COVER 3 86276890 70.
WARNING LIGHTS - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-7 REAR FRONT 1 6 3 4 3 2 5 1 2 6 7 3.
WARNING LIGHTS - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-8 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 8627 0990 57090 4 NUT, 10-32 HEX NYLOCK SS 2 8601 0650 87018 4 WASHER, #10.
SERIAL NUMBERS 86317500 CHARIOT SCRUBBE R 11/15/08 6-9 REF. NO. MODEL: SERIAL # 1 N/A.
Ein wichtiger Punkt beim Kauf des Geräts Windsor 10061090 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Windsor 10061090 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Windsor 10061090 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Windsor 10061090 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Windsor 10061090 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Windsor 10061090 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Windsor 10061090 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Windsor 10061090. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Windsor 10061090 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
