Benutzeranleitung / Produktwartung VCS5005/5010 des Produzenten Vermont Casting
Zur Seite of 31
50002972 7 /05 Rev . 5 En USER’S MANU AL f o r Gas Barbecue Grill M o d el s VCS3505, V C S 3 5 0 5 B I , VCS4005, VCS5005/5010, VCS5005BI, VCS6005 CERTIFIED D E S I G N C E R T I F I E D n w o h S .
Page i FOR YOUR SAFETY If y ou smell gas: • Shut off gas to the appliance; • Extinguish any open flame; • Open lid; • If odor continues, immediately call y our gas supplier or fire department. FOR Y OUR SAFETY Do not store or use gasoline or other flammable v apors and liquids in the vicinity of this or any other appliance.
SIGNAL WORDS: The Signal W ords used in this Manual, and their intended meanings, are as follows : D ANGER : Indicates that a failure to observe the safety instructions could result in death or cata- strophic bodily injury . W ARNING: Indicates that a failure to observe the safety instructions could result in serious bodily injury .
A. SAFE LOCA TIONS FOR USE OF THIS OUTDOOR GRILL D ANGER: • Never use this outdoor Grill inside any building, garage, shed or breezeway , or inside any boat, trailer or recreational vehicle, to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation.
B. SAFE USE OF LP (PR OP ANE) GAS D ANGER: • Never install a propane cylinder that is more than 80 % full, as the contents may lack adequate room for expansion when exposed to heat. Propane vapor may then be vented through the pres- sure release valve, which could accumulate in a pool and later result in a fire or explosion.
• Always promptly shut off the gas supply and immediately extinguish all flames if you smell gas. Always seek assistance from your gas supplier or local Fire Department if the gas smell persists, because of the danger of fire or explosion. • Always confirm that there are no gas leaks before lighting this Grill.
Safety Important W arnings ..................................................... i - v Clearance Requirements ................................................. ii T able of Contents ............................................................ 1 Fuels .
FUELS W ARNING: Never use Natur al Gas in a Grill that has been configured to burn Propane Gas, and never use Propane Gas in a Grill that has been configured to use Natural Gas, to avoid possible bodily injury . Always consult the Rating Label on the back of your Grill to confirm which fuel must be used with the Grill.
D ANGER: a) Do not store a spare LP - Gas Cylinder under or near this appliance b) Never fill the cylinder beyond 80% full; and c) If the information in a) and b) is not followed exactly , a fire causing death or serious injury may oc - cur .
Hooking Up to the LP (Propane) Gas Supply FOR Y OUR SAFETY 1. W ARNING: Never store or use gasoline or any other volatile substance in the vicinity of this Grill. 2. W ARN IN G: N ev er sto re a spa re pro pan e cyl in der in the vicinit y of thi s Grill, or in the vi cini ty of an y other potential heat source.
Natural Gas Supply Connection TO CONNECT : 1. Push back the Sleeve on the Socket as shown below (see Fig. 6a). 2. Insert Plug and release the Sleeve (see Fig.
Control Fu nctions PR OP ANE T ANK V AL VE W ARNING: Never open the T ank V alve unless the Grill is being prepared for use, to prevent the pooling of propane vapor . Always open the V alve immediately before lighting the Grill, and always close it immediately after cooking has been completed.
Lighting the Main Burners 1. Always open the Hood completely and always inspect the Grill and burners to confirm that all components are properly positioned before lighting the main burn- ers. W ARNING: Never stand with your head directly over the Grill when preparing to light the main burners, to prevent possible bodily injury .
T urning the Burners Off 1. Always turn the burner control knob(s) to the OFF position when cooking has been completed. 2. Promptly turn OFF the gas supply valve at the propane cylinder or at the main natural gas supply line. 3. Close the Hood of the Grill.
Lighting the Rotisserie Burner (if applicable) The Rotisserie burner provides the stead y , even heat required to cook poultry and roasts to self-basted per - fection. Please read Assembly Procedures for instructions as well. TO ST AR T THE RO TISSERIE BURNER: 1.
Ro t isser ie Setup ( i f applicab le ) The Rotisser ie bur ner is intended to be use d fo r rotisser ie cooki ng only . W A R NI NG : Nev er use the ma in bu r ners whi le using the Rotisser ie bur ner , as that could result in igniti ng the d r ipping s, or o verheating yo ur G r ill.
Operation Page 1 1 Fig. 13 Control knob Igniter Lighting the Side Burner (if applicable) W ARNING: Never stand with your head directly over the Grill when preparing to light the side burner , to prevent possible bodily injury . 1. Turn the side burner control knob to HIGH (see Fig.
Methods of Cooking W ith its combination of burners and accessories your gas grill can provide for virtually every conceivable style of cooking. • The powerful Main b urners deliver the middle and high range of tempera - tures desired for traditional barbecuing.
One of the keys to extending your range of grilling capabilities is a fundamental understanding of the two common methods of cooking, Direct and Indir ect cooking.
Grilling Tips: A few helpful hints will ensure that your grilling results are perfect every time. • Apply a light coating of cooking oil to your cooking grids before grilling, to prevent foods from sticking. • Cook similar portion sizes together , so that they all cook evenly .
T ype of Food Beef Burgers Roasts Blade, Sirloin T ip Steaks Porterhouse, Rib, Ribeye, Sirloin, T -Bone Filet Mignon Poultry Chicken, Parts Chicken, Whole Chicken Breasts, Boneless Cornish Hens Duck T urkey W eight/ Thickness 1 inch 1 inch 2 inches 3–4 lb.
Cooking T emperature 400–450 ° F . 400–450 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 375–400 ° F . 325–350 ° F .
Cooking T emperature 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 400–450 ° F .
Care & Cleaning W ARNING: Always observe the following safety precautions, to prevent bodily injury and to assure that your Grill will operate properly : CA UTION : Always allow sufficient time for the Grill to cool fully before handling or cleaning any of its parts.
• Cooking Grids The cooking grids have been porcelain enam- eled for durability and ease of cleaning. These Grills may be cleaned with any nonabrasive cleaning agent formulated for kitchen use, or a brass wire brush. NOTE: Always handle the grids with care, as porcelain enamel is susceptible to chipping.
DRIP TRA Y Th e dr ip t ra y an d gr ea se c up , lo cat ed u nd er the burner pan in the bottom of the Grill body are provided to catch excess cooking fats and juices. The drip tray is accessible from the rear of the Grill. It is necessary to lift up the pan slightly while pulling it out (see Fig.
Maintenance BURNER ADJUSTMENT NO TE: It may be necessary to adjust the burners periodically , to compensate for variables in gas char - acteristics. If you notice that the burner flame pattern is irregular (see Figs. 9a, 9b & 9c), it may be necessary to adjust the air shutter opening at the front of the venturi tubes.
Unit won’t stay lit W ind Running out of fuel PROBLEM POTENTIAL CAUSE ACTION REQUIRED Burner will not light Gas supply turned off Out of propane Blockage in the gas system Misalignment of the gas valve to the venturi tubes of the burner .
Blockage in the burner or gas system Corroded burner Improper air shutter opening Excessively fatty foods Grease buildup Uneven burn pattern or Flashback fire Excessive yellow flame Flare-up Electro.
Lifetime W arranty • On all exterior Stainless Steel Components, such as the cart paneling & doors, shelving, condiment bins and handles, if so equipped. • On all castings (1 year on paint). 10 Y ear W arranty • On all porcelain on steel surfaces such as the hood and burn chamber .
CFM Corporation 2695 Meado wv ale Boulev ard Mississaug a, Ontario L5N 8A3 Canada (800) 668-5323 www .cfmcorp .com Service Note: If you are experiencing difficultie s or are dissatisfied with your purchase, please contact CFM at the telephone number listed above prior to returning your grill to the store.
Ein wichtiger Punkt beim Kauf des Geräts Vermont Casting VCS5005/5010 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Vermont Casting VCS5005/5010 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Vermont Casting VCS5005/5010 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Vermont Casting VCS5005/5010 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Vermont Casting VCS5005/5010 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Vermont Casting VCS5005/5010 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Vermont Casting VCS5005/5010 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Vermont Casting VCS5005/5010. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Vermont Casting VCS5005/5010 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
