Benutzeranleitung / Produktwartung Trolleys and Barrows des Produzenten Unigreen
Zur Seite of 28
OPERA TING AND MAINTENANCE MANU AL CR TR OLLEYS AND B ARR O WS 01/200 5 ENGLISH Please read this instruction booklet carefully bef ore use..
2 3 ALLO WED EQUIPMENTS CR 125P CR 125P CR 80 2R CR 75 1R CR 70 1R CR 50P COMET PUMPS Pump MC 20 X X X X X “ “ MP 30 X “ “ MP 40 X “ “ APS 31 X ANNO VI REV . PUMPS Pump AR 252 X X X X X “ “ AR 30 X COMBUSTION MO TORS Oleo Mac 550 X X X X X CM 46 X X X X X B.
2 3 CR 75 1 7 18 2 4 16 10 12 5 9 6 13 8 14 15 19 20 17 3 1 1 21 2 7 13 4 16 1 1 4 18 1 15 17 CR 50 6 10 14 3 5 8 21.
4 5 8 7 18 2 4 16 10 12 5 9 1 14 15 19 17 20 21 CR 80 3 6 1 1 1 7 18 2 4 16 10 12 5 9 13 CR 125 3 6 8 1 1 14 15 17 21.
4 5 22 2 23 16 OFF ON 26 24 27 25 S 2 5 3 4 21 12 1 1 c p h d e f g i o n m l b a 44.
6 7 29 31 30 32 40 33 43 38 42 34 35 39 28 29 30 32 34 43 31 42 40 41 37 33 39 38 36 42 30 37 28 29 33 36 41 39 40 34 31 32 38 31 - bar - psi + bar + psi 32 33 38 29 40 42 29 30 32 41 37 40 28 42 31 3.
6 7 13 12 22 1 4 16 13 16 4 1 12 5.
8 9 SUMMAR Y P AR T ONE 1. GENERAL INFORMA TION _______________________________________9 1.1 TERMS OF THE GUARANTEE .................................................................................. 9 1.2 THE ADDRESS OF THE MANUF ACTURER .............
8 9 I NTR ODUCTION This manual is divided into two separate sections. The rst is for use by the end user and the Skilled T echnician ; the second is for use by the Skilled T echnician alone.
10 1 1 back to the Manufacturer within 10 days of the purchase date with all its parts lled in. The purchaser has sole right to the replacement of the parts that are deemed faulty by the Manufacturer , or by his authorised representative, as regards their material or manufacture.
10 1 1 instructions are also given to the new owner . W e take great care when drawing up our instructions. If you note any mistakes, please do inform the Manufacturer or an authorised service centre. The Manufacturer reserves the right to modify , update and correct these instructions without notice.
12 13 altitude and the room temperature increase (the drop is approximately 3.5% for every 305m / 1000 ft above sea level and 1% for every 5.6°C/42°F above 16°C/61°F). Refer to the combustion engine’ s instructions for any precautionary steps to take if the appliance is to be used at high altitudes or at high room temperatures.
12 13 2.3 IDENTIFICA TION LABEL AND W ARNING LABELS CAUTION • If one or mor e identication labels or warning labels deteriorate during use, contact your dealer or an authorised service centr e so they can be r eplaced.
14 15 2.4 ST ANDARD ACCESSORIES Check that the product purchased is made up of the following parts: • barrow/trolley with the chosen motor-driven pump; • hose reel (if this optional has been chosen); • lever lance with standard nozzle (1.5mm Ø); • operating and maintenance instructions for combustion engine, if any .
14 15 • The appliance must not be used to wash people, animals, ener gized electrical appliances, delicate objects or the appliance itself. • The accessories (standar d and optional) used with the appliance must be those endorsed by the Manufactur er .
16 17 e) Checktheexternalintakelter(5)isclean(onlyforCR75,CR80andCR125). W ARNING • Make sur e ice has not formed inside the pump, hoses and tank if the appliance is used in very low temperatur es.
16 17 W ARNING • For electric appliances with three-phase motors, particular attention must be paid to ensure the direction of rotation of the motor corresponds to that shown on the reducer . If this is not the case, contact a Skilled T echnician who will be able to solve the problem by simply inverting a wire inside the power plug.
18 19 4.2 SPRA YING CAUTION • Pay particular attention to the instructions contained in the section on “ Preparing chemicals for spraying”. • While you ar e spraying, avoid spraying the product on buildings, houses, public or private land, gardens, roads, public or private courses of water and ar eas used by people or animals.
18 19 • Follow the instructions in the “ Switching off” section: - when the appliance is not is use; - before leaving the appliance unattended, even for a short time; - before topping up the chemicals; - after use; • Do not r emove the plug fr om the power outlet by pulling on the power supply cable.
20 21 g) Operate the lever (26) on the lance (13) to achieve the required spraying angle (from an empty cone to a needle-point jet). The adjuster (24) can be used to x the preferred position for spraying. W e recommend this is done while spraying with the lance into the tank to avoid wasting chemicals.
20 21 • Pay particular attention to the instructions contained in the section on “ Preparing chemicals for spraying ”. • Only start cleaning and maintenance once the instructions in the ‘ Switching off ’ section have been completed, i.
22 23 6.2 ROUTINE MAINTENANCE Follow the instructions in the “Switching off” section and in the table below . For appliances tted with a combustion engine, remember to follow the instructions f.
22 23 diaphragm rupture, we recommend you drain the pump crankcase of the mixed oil and pumped liquid and then ll it with oil or diesel to prevent the formation of rust.
24 25 8. DISMANTLING AND DISPOSAL Only trained personnel are allowed to dismantle the appliance in accordance with the current regulations in the country where it is installed. CAUTION • Befor e disposing of the appliance, make sur e it is no longer possible to operate it, by cutting the power supply cable for example.
24 25 P AR T TWO (only for use by Skilled T echnician s) CAUTION • This part of the manual is only for use by Skilled T echnicians and is not meant to be used by the end user of the appliance.
26 27 g) Checktheinationpressureofthepressureaccumulatorandthetyres. h) Checkthelevelofthepumpoilandreduceroil. i) For appliances tted with combustion engine, ll the crankcase with oil as the engines are suppliedwithoutoil.
26 27 SUMMAR Y P AR T ONE 1. GENERAL INFORMA TION _______________________________________9 1.1 TERMS OF THE GUARANTEE .................................................................................. 9 1.2 THE ADDRESS OF THE MANUF ACTURER ...........
UNIGREEN ® S.p.A. via Rinaldi, 105 - 42100 REGGIO EMILIA - IT AL Y T el. (0039) 0522 36981 1 Fax. (0039) 0522 369898 e-mail info@unigreen-spa.com internet www .unigreen-spa.com member of the Y AMA group Decrizioni, illustrazioni indicative, UNIGREEN S.
Ein wichtiger Punkt beim Kauf des Geräts Unigreen Trolleys and Barrows (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Unigreen Trolleys and Barrows noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Unigreen Trolleys and Barrows - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Unigreen Trolleys and Barrows reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Unigreen Trolleys and Barrows erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Unigreen Trolleys and Barrows besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Unigreen Trolleys and Barrows verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Unigreen Trolleys and Barrows. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Unigreen Trolleys and Barrows gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
