Benutzeranleitung / Produktwartung 14AP80RP744 des Produzenten Toro
Zur Seite of 32
Form No. 3354-975 GT2100 Garden T ractor Model No. 14AP80RP744 Register your product at www .T oro.com Original Instructions (EN) 769-02258B (01/10/06) Operator ’ s Manual.
2 TABLE OF CONTENTS FINDING MODEL NUMBER This Operator’s Ma nual is an important part of your new garden tractor. It will help yo u assemble, prepare and maintain the unit fo r best performance.
3 SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out import ant safety instructions which, if not followed, could endanger the personal safe ty and/or property of yourself and others. Read and follow all instruct ions in this manual before attemptin g to operate this machine.
4 19. Slow d own before turning. O perate the machine smoothly. Avoid er ratic operation and excessive speed. 20. Disenga ge blade(s), set parking brake, stop en gine and wait un til the blade(s) com e to a complete stop before removin g grass catcher, emptying grass, unclogging chute, re moving any grass or debris, or making any adjustments.
5 CHILDREN 1. Tragic a ccidents c an occur if the oper ator is not alert to the presence of children. Children are often attracted to the ma chine and the mowing activity . They do not under stand the dangers. Never assume that children will remain where you last saw them.
6 GENERAL SERVICE: 1. Never run an engine indoors or in a poor ly ventilated area. Engine exhaust contains carbon monoxide, an odorless, and de adly gas. 2. Before cleaning, repair ing, or inspecting, make certain the blade( s) and all moving parts have stopped.
7 SECTION 2: SAFETY LABELS Safety labels found on your ga rden tractor are illustrated belo w (3/4 actual size). Always follow their instructions and head their warnings. The label part number is listed below each. If you discover a safety label is scratched , damaged or missing, order a replacement immediately.
8 SECTION 3: INSTRUCTIONAL LABELS Instructional labels fo und on your garden tractor ar e illustrated below (3/4 actual size). Always follow their instructions and heed their warnings. If you discover a label is scratch ed, damaged or missing, order a re placement immediately.
9 SECTION 4: SLOPE GAUGE 3IGHTANDHOLDTHISLEVELWITHAVERTICALTREE ORACORNEROFABUILDING ORAFENCEPOST &OLDALONGDOTTEDLINE.
10 SECTION 5: TRACTOR SET-UP Gas and Oil Fill-up Use only clean, fresh (under 30 da ys old), unleaded gasoline. Fill tank to no more than 1/2 inch below the top of the filler neck to allo w space for fuel expansion. WARNING: Use extreme ca re when handling gasoline.
11 • Make certain the hold-down rod is in position over the batter y, securing it in place. See Figure 2 . Figure 2 NOTE: If the battery is put in to service after the date shown on top /side of ba ttery, cha rge the batt ery as instructed on page 25 of this manual prio r to operating the tractor.
12 SECTION 6: KNOW YOUR GARDEN TRACTOR Figure 5 NOTE: Any ref erence in this manual to the RIGHT or L EFT si de of the tractor is observed f rom operator’s position .
13 Thro tt l e C on t rol The throttle co ntrol lever is located on the right side of the tractor’s dash panel. This lever controls the spee d of the engine.
14 Systems Indicator Monitor / Hour Meter LCD Located in the center of the tra ctor’s cons ole, the systems indicator monitor reco rds, and displays on its LCD, hours of trac tor operati on whenever th e ignition key is rotated out of the STOP po sition.
15 SECTION 7: OPERATING YOUR GARDEN TRACTOR Safety Interlock System This tractor is equipped with a safet y interlock system for the protection of the ope rator. Before each use, check the safety interlock system f or proper operation. If the interlock system should ever malfunction, do not operate the t ractor.
16 Starting the Engine WARNING: Do not operate th e tractor if the interlock system is malfunctioning. This system was designed f or your saf ety and protection. NOTE: Refer to th e TRACTOR SET-UP on page 1 0 of this manual for Gasolin e and Oil fill-up instructions.
17 Setting The Cruise Contr ol NOTE: The cruise contro l feature should only be utilized while traveling in the forward direction. • Slowly depress th e drive pedal until the desired speed is achieved.
18 SECTION 8: MAKING ADJUSTMENTS WARNING: Ne ver atte mpt to make any adjustments while the engine is running, Leveling the Deck NOTE: Check the tractor’ s tire pressure before performing any de ck leveling adjustments. Refer to Tires on page 24 for informati on regarding tire pressure.
19 P arking Brake Adjustment WARNING: Never attempt to a djust the brakes while the engin e is running. Always disengage PTO, mov e shift le ver into neutral position, stop engine and remove key to prevent unint ended starting.
20 SECTION 9: MAINTAINING YOUR GARDEN TRACTOR NOTE: Refer to Maintenance Chart on page 28 for a reference of recommend ed maintenance intervals. WARNING: Before performing any maintenance or rep airs, disengage PTO, set parking brake, st op engine and remove key t o prevent unint ended starting.
21 IMPORT ANT : The engine may overheat and/or damage may result if the oil level is below the ADD or over the FULL on the dipstick. • Reinstall the oil fill cap/dips tick securely onto the oil fill tube. IMPORT ANT : The oil fill cap/dip sti ck must be installed securely onto the tube at all ti mes when the engine is operating .
22 IMPORT ANT : The oil fill cap/dipstick must b e installed securely onto the tube at all ti mes when the engine is operating . Severe engine damage could result from a failure to do so. • Start the tractor engine and allow it to run fo r thirty seconds, then stop the eng ine and remove the ignition key.
23 • Check the gap using a feeler gauge and adjust, if necessary, by carefully bending th e ground electrode. Se e Figure 14. Set the spark plug gap to 0.030 in. (.76 mm) . Figure 14 • Reinstall the spark plug into th e cylinder head. Torque the spark plug to 28/3 2 ft.
24 SECTION 10: SERVICE WARNING: Before servicing, repairing, or inspecti ng, always d isengage PTO, se t parking brake, st op engine and remove key t o prevent unint ended starting. Tire s WARNING: Never exceed the maxim um inflation pressure sh own on the sidewall of the tire.
25 IMPORT ANT : When replacing the bla de, be sure to install the blade with th e side of the blade marked ‘‘Bottom’’ (or with a part number stamped in it ) facing the ground wh en the mower is in the op erating position. IMPORT ANT : Use a torque wrench to tighten the blade spindle hex flange nut to be tween 70 lbs-ft.
26 • Gently slide the cu tting deck toward the front of the tractor allow ing the hoo ks on th e deck to re lease themselves from the deck stabilizer rod.
27 SECTION 11: OFF-SEASON STORAGE Clean and lubricate the tr actor as instructed in Section 7: MAINTAINING YOUR GARDEN TRACTOR on page 20 of this manual before sto ring for an extended period. Engine If the engine will be out of service for tw o months or more, use the followin g storage procedure: • Clean the exterior surfaces of the engine.
28 SECTION 12: MAINTENANCE CHART Before Each Use After Initial 24 Hours Every 10 Hours Every 25 Hours Every 50 Hours Every Season Prior to Storing Clean Hood/Dash Louve rs Check Engine Oil Le v el Cle.
29 SECTION 13: TROUBLESHOOTING T roub le P ossible Caus e(s) Corrective Actio n Engine fails to start PT O (Blade Engage) knob engaged. P arkin g brake not engaged. Spark pl ug wire(s) disconnected. Cchoke control not in correct star ting position. Chok e not activ ated Fuel tank empty , or stale fuel.
30 SECTION 14: SPECIFICATIONS* * Toro reserves the right to change product s pecifications, design, and standard equipment without notice and without incurring oblig ation ** Kohler’s horsepower ra tings exceed Society of Auto motive Engineers Small Engi ne Test Code J1940.
31 CALIFORNIA EMISSION CONTROL W ARRANTY ST A TEMENT Y OUR W ARRANTY RIGHTS AND OBLIGA TIONS The California Air Resources Board and MTD Consumer Group Inc are pleased to explain the ev aporative em ission co ntrol system wa rrant y on your 2006 lawn mower .
32 The T or o Company MANUF ACTURER’ S LIMITED W ARRANT Y FOR L A WN & GARDEN TR AC TORS Customer Care Department of The T oro W arranty Company , 8 111 L yndale A ve . South, Bloomin g ton, MN 55420-1196 or call (US) 1- 888 -3 8 4-9942, (Canada) 1- 888 - 8 4 8 -4073; www .
Ein wichtiger Punkt beim Kauf des Geräts Toro 14AP80RP744 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Toro 14AP80RP744 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Toro 14AP80RP744 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Toro 14AP80RP744 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Toro 14AP80RP744 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Toro 14AP80RP744 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Toro 14AP80RP744 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Toro 14AP80RP744. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Toro 14AP80RP744 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
