Benutzeranleitung / Produktwartung 461230404 des Produzenten Thermos
Zur Seite of 24
461230404 • 80001008 • 10-09-03.
FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP t ank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1.
T ABLE OF CONTENTS W ARRANTY For Y our Safety ......................................2 Grill Service Center ...................................2 Product Record Information ............................2 Installation Safety Precautions ..................
P ARTS LIST – Model No. 461230404 Key Qty Description Part # 1 Grill Lid Assembly ............... 80001001 A 1 Lid Insert ........................ 80000302 B 1 Lid End Cap - Left ................ 80000303 C 1 Lid End Cap - Right ............... 80000304 D 1 Lid Handle .
P ARTS DIAGRAM – Model No. 461230404 461230404 • 5 G H I J N O P Q Q S T U V W X Y Z AA BB CC CC CC CC DD EE FF GG JJ KK LL MM MM NN NN PP QQ R Q RR SS TT UU II OO HH L L B E F C A D E F K M K K R.
6 • 461230404 2 Caster wrench Locking casters on front legs. Attach , non-locking casters to rear legs. T ighten casters using the caster wrench provided. locking casters to front legs ASSEMBL Y – Model No. 461230404 1 Rear view Door brace First 4.
3 4 This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart between the two braces. Align the two holes on each side of the grill head with the two holes on each brace. Make sure the regulator hose is hanging outside the cart.
5 6 Place side shelf over right cart legs. Lip of shelf should fit between grill bottom and leg brace. Secure shelf brackets to cart legs using one screw , lock washer , and flat washer on each bracket. 1/4-20x3/4” (XX) 7mm (YY) 7mm (ZZ) YY ZZ Repeat on front bracket Place sideburner shelf over left cart legs.
7 8 Remove the two screws (M4x10mm) and washers (4mm) from the sideburner valve bracket. Place sideburner valve under front of sideburner control panel so that valve stem comes through large hole. Place sideburner bezel over valve stem. Secure bezel to panel and valve using the two screws and washers you removed from the valve bracket.
10 • 461230404 9 10 Insert valve clip into small hole in bottom of burner , then snap other end of clip over sideburner valve. Beneath sideburner shelf, attach sideburner ignitor wire to electrode. Place brass top on sideburner , then place sideburner grate onto shelf.
12 T o assemble SwingAway , first insert pivot wire into holes in side of grill lid. Second, insert leg wires into holes in sides of grill bottom. Pivot wire Leg wire SwingAway 461230404 • 1 1 Side-to-side wires on bottom. 11 Place cooking grates into grill bottom.
14 Slide condiment baskets into brackets on back of both doors. Smaller basket on left door, larger basket on right door. 12 • 461230404 13 Insert bottom door pin into hole in bottom shelf. Press the top door pin down, align with hole in door brace, release door pin.
461230404 • 13 16 Slide grease tray into back of grill. Make sure drain hole is on left side 15 Hang the two match-lighting sticks and chains from the small hooks on the left and right side panels.
18 See Use & Care manual to perform the “Burner Flame Check” and for important safety instructions before using. Tank valve facing front. Tank valve must face to front of cart once tank is attached. Failure to install tank correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.
461230404 • 15 19 Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+) facing outward. Screw ignitor cap onto ignitor . + – AA Battery 20 Regulator and hose must pass hose bracket before connecting to LP tank. Read “ ” in the Use and Care section of this manual.
16 • 461230404 D ANGER USE AND CARE • Never fill the cylinder beyond 80% full. An overfilled spare LP tank is hazardous due to possible gas released from the safety relief valve. • The safety relief valve on the LP tank could activate, releasing gas, and cause an intense fire with risk of property damage, serious injury or death.
461230404 • 17 WARNING If “growing” bubbles appear do not use or move the LP tank. Contact an LP gas supplier or your fire department! Connecting Regulator To The LP Tank 1. 2. 3. full stop 4. LP tank must be properly secured onto grill. (Refer to assembly section.
18 • 461230404 6. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: do not use this regulator! T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP tank valve, resulting in some resistance.
461230404 • 19 WARNING For Safe Use Of Your Grill And To Avoid Serious Injury: • • • • • • • Use grill at least 3 ft. from any wall or surface. • Apartment Dwellers: • NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.
20 • 461230404 CA UTION If burner does not light, turn knobs to , wait 5 minutes, and try again. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury. OFF Burner Flame Check • Remove grates and flametamers.
461230404 • 21 CA UTION FACT: Sometimes spiders and other small insects climb into the burner tubes attached to the burners. The spiders spin webs, build nests and lay eggs. The webs or nests can be very small, but they are very strong and can block the flow of gas.
22 • 461230404 Indirect Cooking Indirect Cooking Instructions Poultry and large cuts of meat cook slowly to perfection on the grill by indirect heat. The heat from selected burners circulates gently throughout the grill, cooking meat or poultry without the touch of a direct flame.
461230404 • 23 Troubleshooting Problem Burner(s) will not light using ignitor . Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)). Unable to fill LP tank.
A Division of W .C. Bradley Co. • Columbus, GA 31902 Troubleshooting - Electronic Ignition Problem No sparks appear at any electrodes when ignition button is pushed; no noise can be heard from spark module. No sparks appear at any electrodes when ignition switch is pushed; noise can be heard from spark module.
Ein wichtiger Punkt beim Kauf des Geräts Thermos 461230404 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Thermos 461230404 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Thermos 461230404 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Thermos 461230404 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Thermos 461230404 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Thermos 461230404 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Thermos 461230404 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Thermos 461230404. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Thermos 461230404 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
