Benutzeranleitung / Produktwartung CASTLEWOOD 42 des Produzenten Hearth and Home Technologies
Zur Seite of 43
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 1 Owner ’ s Manual Installation and Operation Models: Outdoor Woodburning Castlewood 42 DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 2 Read this manual before installing or operating this replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Outdoor Lifestyles wood burning replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started A. Design and Installation Considerations .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 4 1 L isting and Code Approv als A. Appliance Certication This replace system has been tested and listed in accor- dance with UL 127 and CAN/ULC-S610-M87 standards by Underwriters Laboratories Inc.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 5 2 Gett ing Star ted A. Design and Installation Considerations Check building codes prior to installation. • Installation MUST comply with local, regional, state and national codes and regulations.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 6 F . Grate This replace is designed to be used with the grate sup- plied with this unit or one approved by HHT . The grate will deteriorate over time and will need occasional replace- ment.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 7 3 F raming and C learanc es A. Selecting Fireplace Location This outdoor replace will shed moderate amounts of water , but is not waterproof. Water and condensing water vapor may enter the chase under certain conditions.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 8 Figure 3.1 Fireplace Locations FREEST ANDING INST ALLA TION (Combustible Structure) (Enclosed Fireplace) 10 ft Min.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 9 B. Clearances Fire Risk • Comply with all minimum clearances to combustibles as specied.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 10 2 in./51 mm minimum air space clearance to the enclosure. Use only noncombustible material below the top of the top standoffs. 28-3/8 in. 721 cm 74-1/2 in. 1892 cm 53- 7/8 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 1 1 E. Chimney Requirements When planning your replace location, the chimney construc- tion and necessary clearances must be considered. The re- place system and chimney components have been tested to provide exibility in construction.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 12 4 Installation of F ireplace Position the Fireplace This replace may be placed on either a combustible or noncombustible continouous at surface. Follow the instructions for framing in Section 3.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 13 W ARNING! Cooling air must be provided when install- ing in combustible enclosure or on combustible surface. • Locate cooling air hoods to prevent blockage from leaves, snow/ice, or other debris.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 14 V ertical distances are measured from the base of the re- place. • Minimum overall straight height is 10 ft. if the replace is freestanding and a minimum of 10 ft from a combustible structure.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 15 B. Assemble the Chimney Sections install substitute or dam- aged chimney components.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 16 C. Using Offsets/Returns T o bypass any overhead obstructions, the chimney may be offset using an of fset/return. An offset and return may be attached together or a chimney section(s) may be used between an offset and return.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 17 6 Complete th e Enclos ure B. Chase T op A metal chase top is required to seal the top of the chase around the chimney pipe. The top should include a turn- down and drip edge to prevent water from seeping into the chase.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 18 TCT1 175 T erra Cotta Cap Chimney Pipe Chase T op T ermination Cap Chase Collar 2 in. (51 mm) Minimum Height Remove 2 screws from front & back to lift the top off T ermination cap pipe and chimney section must overlap 1-1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 19 7 Installation of Mold ed Brick Panel A. Install Hearth Molded Brick Panel 1. Put a level on replace to verify it is level side to side and front to back. 2.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 20 E. Mortar (Optional) The non-combustible finishing material across the top of fireplace opening will be even with lower edge of metal face. Non-combustible finishing materials MUST overlap side faces by 1 1/4 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 21 8 Accessories Figure 8.1 Gas Line Installation A. Gas Log/Lighter Provisions A certied gas log lighter or decorative gas log set can be installed in this replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 22 9 Fin ishing A. Non-combustible Materials • Materials which will not ignite and burn, composed of any combi.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 23 D. Raised Hearth Extension Framing The hearth framing must be constructed of non-combustible materials (Figure 12.2) and placed on 1/2 in. Durock and 1 in. Micore (or equivalent material) (Figure 12.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 24 E. Non-combustible Sealant After completing the framing and applying the facing ma- terials over the framing,.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 25 F . Finishing Material Refer to Sections 9.A. and Sections 9.B. for combustible/ non-combustible materials. Refer to Figure 9.2 for non-com- bustible zone if cooling air hoods are installed.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 26 G. Mantel Figure 9.3 Clearance to Mantel or other non-combustilbes above replace • Refer to the shaded areas of Figure 9.3 for the location and dimensions of a combustible mantel.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 27 1 0 Op erating Instruc tions Fire Risk • Do not operate replace before reading an d und ers tan din g ope rat ing in str uct ion s. Failure to operate replace properly may cause re.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 28 C. Clear Space Near the Fireplace Combustible materials must not be stored on the hearth ex- tension. Outdoor room furnishings such as chairs or other combustibles must be at least 4 ft (1.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 29 F . Wood Fuel Firewood Y our replace performance depends on the quality of the rewood you use. All seasoned wood, regardless of spe- cies, contains about 8,000 BTU’s per pound, and hard- woods have a greater density than soft woods.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 30 G. Starting a Fire Place crumpled or twisted paper under the replace grate. Loosely arrange kindling or small pieces of wood to form a layer above the paper .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 31 1 1 T roubleshooting A. Diagnostics and Problem Solving I can’t get a good re going. What am I doing wrong? Diagnostic Questions Possible Causes of Condition Solutions Is the damper open? • No draft Open damper .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 32 1 2 Maintenance and Ser vicing the F ireplace A. Disposal of Ashes Ashes should be placed in a metal container with a tight- tting lid.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 33 Handle glass assembly with care. When cleaning glass door: • Avoid striking, scratching or slamming glass. • Do NOT use abrasive cleaners. • Use a hard water deposit glass cleaner on white lm.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 34 1 3 Reference Mater ials A. Fireplace Dimensions.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 35 B. Optional Components ODGF42-BZ Glass Doors (optional) See your Hearth & Home dealer for a complete list of optional components.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 36 C. Chimney Components The following pictures show only those chimney components which may be safely used with this replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 37 21 in. (533 mm) Inside Diameter 1 1 in. (279 mm) Outside Diameter 13 in. (330 mm) SL1 130 Offset/Return A B 17 in. (432 mm) 2 in. (51 mm) 13 in. (330 mm) JB577 Chimney Joint Band 13 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 38 15-3/4 in. (400 mm) 32-3/8 in. (822 mm) 34-3/8 in . (873 mm) TR1 1T - Round T elescoping T ermination Cap ST1 175 - Square T ermination Cap 9-3/8 in. (238 mm) 10-1/4 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 39 Service Parts 08/10 42 in. Woodburning Fireplace Part numbers on following page.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 40 Service Parts List ODCASTLEWD-42 Service Parts 08/10 42 in. Woodburning Fireplace Part numbers on following page.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 41 Outdoor Lifestyles by Hearth & Home T echnologies, Inc.™ Limited W arranty Hearth & Home T echnologies, Inc.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 42 Limited W arranty • Damages resulting from: (1) failure to install, opera.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 43 – NOTES – G. Contact Information DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation.
Ein wichtiger Punkt beim Kauf des Geräts Hearth and Home Technologies CASTLEWOOD 42 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Hearth and Home Technologies CASTLEWOOD 42 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Hearth and Home Technologies CASTLEWOOD 42 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Hearth and Home Technologies CASTLEWOOD 42 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Hearth and Home Technologies CASTLEWOOD 42 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Hearth and Home Technologies CASTLEWOOD 42 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Hearth and Home Technologies CASTLEWOOD 42 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Hearth and Home Technologies CASTLEWOOD 42. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Hearth and Home Technologies CASTLEWOOD 42 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
