Benutzeranleitung / Produktwartung 42 des Produzenten Hearth and Home Technologies
Zur Seite of 44
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 Owner ’ s Manual Installation and Operation Models: Montana-36 Montana-42 Woodburning Fireplace DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 2 Read this manual before installing or operating this replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Outdoor Lifestyles wood burning replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started A.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 4 1 Listing and C od e Appro vals A. Appliance Certication This replace system has been tested and listed in accor- dance with UL 127 and CAN/ULC-S610-M87 standards by Underwriters Laboratories Inc.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 5 2 Get ting Star t ed A. Design and Installation Considerations Draft is the pressure difference needed to vent replaces successfully .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 6 Before beginning the installation be sure the following tools and building supplies are availab.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 7 3 F raming and Clearances A. Selecting Fireplace Location This outdoor replace will shed moderate amounts of water , but is not waterproof.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 8 B A H F Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D G G C D H G F J I E Figure 3.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 9 0 in. 0 in. to level of standoffs Combustible Object 36 in. (914 mm) 1-1/2 in. (38 mm) Drywall 0 in. 1/2 in. (13 mm) 1-1/2 in. (38 mm) B. Clearances Figure 3.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 10 2 in./51 mm minimum air space clearance to the enclosure. Use only noncombustible material below the top of the top standoffs. 28-3/8 in. 721 cm 74-1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 1 E. Chimney Requirements When planning your replace location, the chimney construc- tion and necessary clearances must be considered.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 12 72 in./183 cm min. TR1 1/TR444 T ermination Cap A. Install the Dual Cooling Air Kit The cooling air kit is supplied as a standard feature with this replace and is required for safe operation.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 13 B. Secure the Fireplace • Position the Fireplace This replace may be placed on either a combustible or noncombustible continuous at surface.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 14 A. Chimney Requirements V ertical distances are measured from the base of the re- place. • Minimum overall straight height is 6 ft 4 in. if the replace is fre est andi ng and a min imu m of 10 ft fro m a comb ust ibl e structure.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 15 B. Using Offsets/Returns T o bypass any overhead obstructions, the chimney may be offset using an of fset/return. An offset and return may be attached together or a chimney section(s) may be used between an offset and return.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 16 C. Assemble the Chimney Sections Attach either a straight chimney section or an offset to the top of the replace (depending on your installation require- ment).
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 17 E. Install the Attic Insulation Shield An insulation shield must be installed when there is a pos- sibility of insulation coming into contact with the factory built chimney system.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 18 6 Complete the Enclosure Figure 6.1 Multiple Chimneys A.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 19 T ermination Cap Storm Collar Slope Downward T urn-down Drip Edge Chase (Chimney) 2 in. (51 mm) Collar on Chase T op Caulk .018 (26 ga) min. Galvanized Chase T op Figure 6.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 20 Not e : T o protect against the ef fect of cor rosio n on t hose par ts exposed to the weather , t he ter mination cap can be painted with a r ust-resist ant paint.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 21 • TCT1 175 T erra Cotta Cap Chimney Pipe Chase T op T ermination Cap Chase Collar 2 in. (51 mm) Minimum Height Remove 2 screws from front & back to lift the top off T ermination cap pipe and chimney section must overlap 1-1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 22 A. Gas Log/Lighter Provisions A certied gas log lighter or decorative gas log set can be installed in this replace. This replace was not tested and listed for use with an un- vented gas log heater .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 23 8 F inishing A. Hearth Extension A hearth extension must be installed with all replaces to protect the combustible oor in front of the replace from both radiant heat and sparks.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 24 B. Finishing Material • Combustible Material Material which is made of or surfaced with wood.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 25 9 Operat ing Instruct ions A. General Information Fireplaces, as well as other woodburning appliances, have been used safely for many years.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 26 D. Flue Damper The ue damper must be in full open position, and is oper- ated by moving the handle up toward the top of the replace. Before lighting the re, verify this by looking up from the in- side of the replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 27 G. Grate The factory installed integral grate must be used to hold the logs from falling out of an open replace and to allow air to pass between the burning logs.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 28 I. Starting a Fire Check the ue damper to be certain it is in the full open po- sition. Place crumpled or twisted paper under the replace grate.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 29 Diagnostics and Problem Solving 1 0 T roubleshooting I can’t get a good re going. What am I doing wrong? Diagnostic Questions Possible Causes of Condition Solutions Is the damper open? • No draft Open damper .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 30 A. Disposal of Ashes Ashes should be placed in a metal container with a tight-t- ting lid.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 31 Fire Risk • Do not use chimney cleaners or ame colorants in your replace. Will corrode chimney . W ARNING D. Maintenance T ask List Asphyxiation Risk Fire Risk Annual inspection by qualified technician recommended.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 32 1 2 Reference Materials A. Fireplace Dimensions C 23 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 33 B. Fireplace Components Bi-fold Glass Doors Herringbone Pattern Refractory T raditional Brick Pattern Refractory 20 in. (508 mm) 66 in. (1676 mm) 1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 34 C. Chimney Components The following pictures show only those chimney components which may be safely used with this replace. 13 in. (330 mm) 14 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 35 A B 17 in. (432 mm) Ceiling Firestop Assembled Diameter: 17 in./432 mm Height: 24 in./610 mm AS10 Straight Attic Insulation Shield 2 in. (51 mm) 13 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 36 72 in. (1829 mm) 36 in. (914 mm) 2 in. (51 mm) 13-3/8 in. (340 mm) CT56 Chase T op A B C D LDS33/LDS46 Decorative Shroud TR1 1/TR444 Round T ermination Cap 15-3/4 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 37 Woodburning T ermination Cap Shroud TS345/T445 (T op V ent) TR342/TR344 TR442/TR444 TV342 .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 38 D. Service Parts Service Parts 06/1 1 36” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 Part number list on following page.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 39 D. Service Parts (continued) Service Parts 06/1 1 42” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 MONT ANA-42, MONT ANA-42H Part number list on following page.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 40 This page intentionally left blank..
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 41 This page intentionally left blank..
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 42 E. Limited W arranty Outdoor Lifestyles by Hearth & Home T echnologies, Inc.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 43 Limited W arranty (continued) • Damages resulting from: (1) failure to install, operate,.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 44 – NOTES – F . Contact Information DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation.
Ein wichtiger Punkt beim Kauf des Geräts Hearth and Home Technologies 42 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Hearth and Home Technologies 42 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Hearth and Home Technologies 42 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Hearth and Home Technologies 42 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Hearth and Home Technologies 42 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Hearth and Home Technologies 42 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Hearth and Home Technologies 42 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Hearth and Home Technologies 42. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Hearth and Home Technologies 42 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
