Benutzeranleitung / Produktwartung 00941-3 des Produzenten Generac Power Systems
Zur Seite of 52
Owner’ s Man ual and Installation Instructions Air -cooled Recreational V ehic le Generator • Model No: 00941-3 IMP A CT -36 plus II with In ver ter This manual should remain with the unit.
Generac ® Pow er Systems, Inc. I NTRODUCTION Thank you for purchasing this generator by Generac P ower Systems, Inc. This model is designed and man- ufactured to supply electrical power for recreational vehicles.
T able of Contents IM P ACT -36 plus II Recreational V ehicle Generator Generac ® Pow er Systems, Inc. 1 P ar t I – Owner’s Manual Introduction ....................................................Inside Front Cover Read This Manual Thoroughly ...
2 Generac ® Pow er Systems, Inc. Study these SAFETY RULES carefully before installing, operating , or servicing this equipment. Become familiar with this manual and with the unit. The generator can operate safely , efficiently , and reli- ably only if it is properly installed, operated, and maintained.
Generac ® Pow er Systems, Inc. 3 • When working on this equipment, remain alert at all times. Never work on the equipment when physically or mentally fatigued. • Inspect the generator regularly , and contact the nearest Generac Authorized Service Dealer imme- diately for parts needing repair or replacement.
4 Generac ® Pow er Systems, Inc. Section 1 – General Information IM P ACT -36 plus II Recreational V ehicle Generator IM P ACT 36 plus II Recreational V ehicle Generator 1.1 GEN ER A T OR I DENTI F ICA TION Please recor d the following information from the generator DA T A DECAL or information decal, located below the user control panel.
Generac ® Pow er Systems, Inc. 5 Section 1 – General Information IM P ACT -36 plus II Recreational V ehicle Generator 1.1.2 I NVERTER FEA TU R E S (P ART NO.
6 Generac ® Pow er Systems, Inc. Section 1 – General Information IM P ACT -36 plus II Recreational V ehicle Generator 1.2 GEN ER A T OR AP P LICAB I LIT Y These generators have been designed and manufac- tured for supplying electrical power for recreational vehicles.
Generac ® Pow er Systems, Inc. 7 Section 2 – Operation IM P ACT -36 plus II Recreational V ehicle Generator 1.4.5 HOU R METER Indicates the time the engine -generator has operated, in hours and tenths of hours. Use the hourmeter along with the periodic maintenance schedule for the generator set.
8 Generac ® Pow er Systems, Inc. Section 2 – Operation IM P ACT -36 plus II Recreational V ehicle Generator 2.1.4 COOLING AN D VENTIL A TI NG AIR Air inlet and outlet openings in the generator com- partment must be open and unobstructed for contin- ued proper operation.
Generac ® Pow er Systems, Inc. 9 Section 2 – Operation IM P ACT -36 plus II Recreational V ehicle Generator 2.4 AP P L YI NG L O ADS T O GEN ER A T OR When applying electrical loads to the generator , observe these guidelines: • Before applying electrical loads, let the generator stabilize and warm up for a minute or two.
10 Generac ® Pow er Systems, Inc. Section 3 – Maintenance IM P ACT -36 plus II Recreational V ehicle Generator 3.1 MAI NTENANCE This section includes information about simple maintenance which includes the following tasks: • Checking engine oil level.
Generac ® Pow er Systems, Inc. 11 Section 3 – Maintenance IM P ACT -36 plus II Recreational V ehicle Generator 3.5 ENGI N E AI R CLEAN ER Paper F ilter: Once every 25 operating hours or once each year (whichever comes first), clean or replace the paper filter (Figure 3.
12 Generac ® Pow er Systems, Inc. Section 3 – Maintenance IM P ACT -36 plus II Recreational V ehicle Generator Do NOT use a forceful spray of water to clean the generator . W ater will enter the generator interior and cause problems, and may also contaminate the generator fuel system.
Generac ® Pow er Systems, Inc. 13 Section 3 – Maintenance IM P ACT -36 plus II Recreational V ehicle Generator 2. When valve clearance is correct, hold the pivot ball stud with the allen wrench and tighten the rocker arm jam nut with a crows foot. Tighten the jam nut to 65-85 inch-pounds torque.
14 Generac ® Pow er Systems, Inc. Section 4 – Notes IM P ACT -36 plus II Recreational V ehicle Generator.
P ART I I – I NS T ALL A TION I NS TR UCTIONS ONL Y QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD A TTEMPT INST ALLA TION!! D ANGER.
16 Generac ® Pow er Systems, Inc. Safety Rules IM P ACT -36 plus II Recreational V ehicle Generator NO TICE T O I NS T ALLER These Installation Instructions have been published by Generac to aid in the installation of the products described in this manual.
Generac ® Pow er Systems, Inc. 17 ELE CTR ICAL HA Z AR DS • The generator covered by this manual produces dangerous electrical voltages that can cause fatal electrical shock. A void contact with bare wires, ter- minals, connections, etc., while the unit is running .
18 Generac ® Pow er Systems, Inc. 1.1 P U R POSE AND S C OP E OF TH E MAN U AL These Installation Instructions have been prepared especially for the purpose of familiarizing installers and owners of the applicable equipment with the product's installation requirements.
Generac ® Pow er Systems, Inc. 19 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.1 L OCA TION AN D SU P PORT 2.1.1 GEN ERA T OR L OCA TION The most desirable location for the generator set is between the vehicle's main frame members However , this is seldom possible.
20 Generac ® Pow er Systems, Inc. Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.1.4 GEN ERA T OR R E STRAI NT Use four 5/16"-18 hardened steel bolts (Grade 5) to fasten the generator to the supporting frame or the support tubing .
Generac ® Pow er Systems, Inc. 21 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.2.1 COMP ARTM ENT SIZE Plan the compartment size carefully .
22 Generac ® Pow er Systems, Inc. Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.2.3 SOUN D INSU L A TING MA TER IAL S Once installers have determined that compartments are properly constructed and metal lined, they can add acoustical material.
Generac ® Pow er Systems, Inc. 23 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.2.5 AC OUSTIC S If excessive noise levels should become a problem, the installer may wish to consider the following: • Using special sound insulating materials.
24 Generac ® Pow er Systems, Inc. Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.3.2 COOLING AI R IN LET OPEN I NGS Provide three air inlet openings, whether the genera- tor is housed in a conventional compartment or not.
Generac ® Pow er Systems, Inc. 25 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.3.3 COMP ENS A TI NG FOR R ES TRICTIONS Such materials as screening, louvers, or expanded metal can restrict the free flow of air . Compensate for this restriction by making the actual air opening pro- portionately larger .
26 Generac ® Pow er Systems, Inc. Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.4.2 SOME I MPORT ANT CONSIDER A TIONS When installing an LP gas system, consider seriously the following items: • All fittings, lines, hoses and clamps must be tight and free of leaks.
Generac ® Pow er Systems, Inc. 27 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator • The regulator must be sensitive to venturi throat pressure changes throughout the operating range.
28 Generac ® Pow er Systems, Inc. Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator F ailure to provide and maintain a spark arrestor may be in violation of the law . If this generator is used on any forest covered, brush covered, or grass covered unimproved land, provide a spark arrestor .
Generac ® Pow er Systems, Inc. 29 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator • W iring must be of adequate size, with approved insulative qualities, and properly supported.
30 Generac ® Pow er Systems, Inc. Figure 2.20 — T ransfer Switch Isolation Method Figure 2.21 — Installation with Isolation Receptacle INVERTER INVERTER PO WER CORD FOR DOCKSIDE PO WER PO WER SUP.
Generac ® Pow er Systems, Inc. 31 Section 2 – Installation IM P ACT -36 plus II Recreational V ehicle Generator 2.6.6 SENSI NG HARN ES S A sensing harness has been provided with the gener- ator to connect to the inverter (Figure 2.22). It is 12 feet long, however , it is also available in a 24 foot length: Model # 04612-0.
32 Generac ® Pow er Systems, Inc. * F or warm weather , use No. 2 cable up to 20 feet. 2.7 .3 BA T TER Y CAB LE C ON N E CTIONS 1. Connect the battery cable from the battery post or terminal indicated by a POSITIVE, POS or (+) to the large lug on the starter contactor as indicated in Figure 2.
Generac ® Pow er Systems, Inc. 33 3.1 POS T I NS T ALL A TION TE S TS The air cooled Impact -36 plus II generator set was factory tested and adjusted using gasoline as fuel.The air cooled Impact -34 plus II generator set was factory tested and adjusted using LP gas as fuel.
34 Generac ® Pow er Systems, Inc. Section 3 – Post-installation Start-up Checks IM P ACT -36 plus II Recreational V ehicle Generator 3.5 I NS T ALL A TION CH ECKLIS T L OCA TION AN D SUP PORT ❑ Generator is properly located. ❑ Generator is properly supported.
Generac ® Pow er Systems, Inc. 35 Section 4 – T roubleshooting IM P ACT -36 plus II Recreational V ehicle Generator 4.1 TROU B LE SHOO TI NG GU I DE P ROB LEM CAUSE C OR R E CTION Engine won't crank. 1. Fuse is blo wn. 1. Replace 15 amp fuse. 2.
36 Generac ® Pow er Systems, Inc. Section 5 – Notes IM P ACT -36 plus II Recreational V ehicle Generator.
Section 6 — Electrical Data IM P ACT -36 plus II Recreational V ehicle Generator Major Features and Dimensions – Drawing No. 0E7 56 1 Generac ® Pow er Systems, Inc.
38 Generac ® Pow er Systems, Inc. Section 6 — Electrical Data IM P ACT -36 plus II Recreational V ehicle Generator Wiring Diagram and Schematic – Drawing No.
Generac ® Pow er Systems, Inc. 39 Section 6 — Electrical Data IM P ACT -36 plus II Recreational V ehicle Generator Wiring Diagram and Schematic – Drawing No.
40 Generac ® Pow er Systems, Inc. 36 6 44 47 8 35 49 27 4 10 3 28 22 2 9 13 2 11 21 14 40 9 15 1 19 19 17 14 16 46 23 8 9 5 41 9 26 41 3 1 38 25 4 3 27 26 7 12 31 42 22 3 7 22 10 30 20 48 33 34 45 24 5 1 50 Section 7 — Exploded Views and P ar ts Lists IM P ACT -36 plus II Recreational V ehicle Generator Control Panel – Drawing No.
Generac ® Pow er Systems, Inc. 41 ITEM P A RT N O. Q TY . DESCRIPTION 1 091526 7 M5-0.8 X 12MM PHILLIPS P AN HD . MACH. SCR. 2 020093 1 BO X, CONTROL TOP 3 0E7556 1 BO X, CONTROL P ANEL 4 075477 1 SCREW PPHM M5-0.8 X 20 5 051716 1 M5-0.8 HEX NUT 6 074908 8 T APTITE M5- .
5 35 7 8 6 3 3 34 2 3 44 53 30 2 9 5 25 39 2 2 3 3 2 0 21 22 54 2 6 4 7 5 30 4 2 3 11 22 38 3 11 24 3 1 4 0 41 31 32 39 77 72 7 8 66 5 71 7 3 74 7 6 7 0 2 12 1 9 17 5 1 8 80 65 42 63 64 61 68 67 4 3 4.
ITEM P ART NO . QTY . DESCRIPTION 1 086705 1 PLA TE, DIVIDER 2 056893 32 CRIMPTITE 10-24 x 1/2" 3 086718 3.5' SEAL, R UBBER EXTR USION 4 0A3666 1 BO X, WRAPPER 5 074908 31 T APTITE, M5-.8 x 10MM 6 0A3667 2 MOUNTING RAILS 7 022129 12 M8 LOCK W ASHER 8 039414 4 M8-1.
44 Generac ® Pow er Systems, Inc. 5 4 3 6 7 1 2 7 14 10 5 49 50 3 4 28 13 5 2 8 1 18 17 5 1 25 22 33 3 2 58 42 19 59 23 24 11 13 3 7 17 4 39 40 38 21 26 30 53 3 1 48 43 45 46 44 47 36 Section 7 — Exploded Views and P ar ts Lists IM P ACT -36 plus II Recreational V ehicle Generator GN 22 0 RV Long Block – Drawing No.
Generac ® Pow er Systems, Inc. 45 ITEM P A RT N O. Q TY . DESCRIPTION 1 078621 1 ASSY , CONNECTING ROD 2 076389 1 PIST ON PIN 3 088411 1 PIST ON RING SET 4 072657A 2 PLUG, 1/4 NPTF PIPE 5 077176 1 CO.
Section 7 — Exploded Views and P ar ts Lists IM P ACT -36 plus II Recreational V ehicle Generator Generator – Drawing No. 0D4945-A 46 Generac ® Pow er Systems, Inc.
ITEM P ART NO . QTY . DESCRIPTION 1 0A2467 1 ENGINE, LONG BLOCK 2 094583 1 FL YWHEEL, F AN 3 083312 2 W ASHER, CONICAL 4 081810 2 HEX NUT , M16-1.5 5 070185 1 FIL TER, OIL 6 086730 1 TUBE, EXHA UST OUTLET 7 089476 1 GASKET , EXHA UST 8 040976 4 SOCKET HD .
48 Generac ® Pow er Systems, Inc. Section 8 – W arranty IM P ACT -36 plus II Recreational V ehicle Generator CALIFORNIA AND FEDERAL EMISSION CONTR OL W ARRANTY ST A TEMENT Y OUR W ARRANTY RIGHTS AN.
Generac ® Pow er Systems, Inc. 49 Section 8 – W arranty IM P ACT -36 plus II Recreational V ehicle Generator EMISSION CONTROL SYSTEM W ARRANTY Emission Control System Warranty (ECS W arranty) for 1997 and later model year engines: (a) Applicability: This warranty shall apply to 1997 and later model year engines.
Part No. 0E7558 Revision 0 (08/21/03) Printed in U.S.A. Section 8 – W arranty IM P ACT -36 plus II Recreational V ehicle Generator GENER AC PO WER SY S TEMS’ TH REE- YEAR LI M ITED W AR R ANT Y FOR GUARDIAN RECR EA TIONAL VEH ICLE GEN ER A T ORS NOTE: ALL UNITS MUST BE INST ALLED BY GENERAC POWER SYSTEMS A UTHORIZED SERVICE F ACILITIES.
Ein wichtiger Punkt beim Kauf des Geräts Generac Power Systems 00941-3 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Generac Power Systems 00941-3 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Generac Power Systems 00941-3 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Generac Power Systems 00941-3 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Generac Power Systems 00941-3 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Generac Power Systems 00941-3 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Generac Power Systems 00941-3 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Generac Power Systems 00941-3. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Generac Power Systems 00941-3 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
