Benutzeranleitung / Produktwartung VFCM-25-3. VFCR-25-3 des Produzenten Empire Comfort Systems
Zur Seite of 24
Page 1 16937-4-0806 I NST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL CAST IRON UNVENTED ROOM HEA TER MODELS VFCM-25-3 VFCR-25-3 VFCT -25-3 WAT E R V A P O R : A B Y- P R O D U C T O F UNVENTED ROOM HEA TERS W ater vapor is a by-product of gas combustion.
Page 2 16937-4-0806 SECTION P AGE Important Safety Information ....................................................................................................................................................... 3 Safety Information for Users of LP Gas .
Page 3 16937-4-0806 When used without adequate combustion and ventilation air, heater may give off CARBON MONOXIDE, an odorless, poisonous gas. Do not install heater until all necessary provisions are made for combustion and ventilation air .
Page 4 16937-4-0806 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. Y ou must find out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detect that odor .
Page 5 16937-4-0806 INTRODUCTION I nstructions to Installer 1. Installer must leave instruction manual with owner after installation. 2. Installer must have owner fill out and mail warranty card supplied with unvented room heater . 3. Installer should show owner how to start and operate unven ted room heater .
Page 6 16937-4-0806 W A TER V APOR: A BY -PRODUCT OF UNVENTED ROOM HEA TERS W ater vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for every 1,000 BTU's (.3KW's) of gas input per hour .
Page 7 16937-4-0806 GAS SUPPL Y Check all local codes for requirements, especially for the size and type of gas supply line required. Note: Never use plastic pipe.
Page 8 16937-4-0806 Figure 2 Figure 3 Figure 4 When facing the front of the appliance the following minimum clearances to combustible construction must be maintained.
Page 9 16937-4-0806 Figure 6 Figure 5 FLANGE TOW ARDS BACK DET AIL VIEW RIGHT SIDE REAR COVER LEFT SIDE (4) LEVELING BOL TS Figure 7 CASING BOTTOM.
Page 10 16937-4-0806 LOG PLACEMENT Every burner is shipped with a protective cover . This cover must be removed before log placement. The posi tio nin g of the logs is crit ic al to th e saf e and cl ean oper ati on of this heater . Sooting and other problems may result if the logs are not properly and firmly positioned in the appliance.
Page 1 1 16937-4-0806 Proper Log Placement Log placement is critical to proper burner performance. Logs must be correctly positioned onto the burner . The photos in this manual show the proper pinned position for logs on this set. Owners need to be shown proper log placement and instructed not to move the logs.
Page 12 16937-4-0806 VFCR -25, VFCT -25 PHOTOS.
Page 13 16937-4-0806 OPERA TION INSTRUCTIONS/FLAME APPEARANCE Flames from the pilot (rear right back side of the pan burner) as well as the main flame should be visually checked as the log set is installed. In normal operation at full rate after 10 to 15 minutes, the flame appearance should be sets of yellow flames.
Page 14 16937-4-0806 FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand.
Page 15 16937-4-0806 HI/LO REGULA TOR CONTROL KNOB PIEZO IGNITOR FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life.
Page 16 16937-4-0806 FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand.
Page 17 16937-4-0806 Figures 13 and 16 show a correct pilot flame pattern. The correct flame will be blue and will extend beyond the thermocouple. The flame will surround the thermocouple just below the tip. A slight yellow flame may occur where the pilot flame and main burner flame meet.
Page 18 16937-4-0806 PILOT FLAME CHARACTERISTICS (continued) Cleaning and Maintenance/Pilot Oxygen Depletion Sensor Pilot When the pilot has a large yellow tip flame, clean the Oxygen Depletion Sensor as follows: 1. Clean the ODS pilot by loosening nut B from the pilot tubing.
Page 19 16937-4-0806 MILLIVOL T OPERA TING INSTRUCTIONS VFCR-25 ON/OFF/REMOTE Switch VFCR-25 is equipped with an ON/OFF/REMOTE switch which is located on the wiring chase. A wire harness is attached to the ON/OFF/REMOTE switch. The brown, black and green (wires) female push-ons attach to the ON/OFF/REMOTE switch.
Page 20 16937-4-0806 OPERA TING GUIDELINES Before operating this heater , please review the safety warnings pages at the beginning of this manual and those precautions and warnings listed below . 1. Know what type of ignition system this model has (standing pilot) and follow the applicable SAFETY and LIGHTING instructions.
Page 21 16937-4-0806 IMPOR T ANT : Operating heater where impurities in air exist may create odors. Cleaning supplies, paint, paint remover , cigarette smoke, cements and glues, new carpet or textiles, etc., create fumes. These fumes may mix with combustion air and create odors.
Page 22 16937-4-0806 1 R-5029 CASTING TOP 2 R-5028 CASTING SIDE LEFT 3 R-5027 CASTING SIDE RIGHT 4 R-5026 CASTING FRONT 5 10659 CASING BOTTOM ASSEMBL Y 6 10541 CASING BACK USE ONL Y MANUF ACTURER'S REPLACEMENT P AR TS. USE OF ANY OTHER P AR TS COULD CAUSE INJUR Y OR DEA TH.
Page 23 16937-4-0806 Parts can be ordered only through your service person or dealer . For best results, the service person or dealer should order parts through the distributor . Parts can be shipped directly to the service person/dealer . All parts listed in the Parts List have a Part Number .
Page 24 16937-4-0806 SER VICE NOTES Empire Comfort Systems, Inc. Nine Eighteen Freeburg A ve. Belleville, Illinois 62222-0529 PH: 1-800-851-3153 PH: 1-618-233-7420 F AX: 1-800-443-8648 F AX: 1-618-233-7097 E-MAIL: info@empirecomfort.com WEB SITE: www .
Ein wichtiger Punkt beim Kauf des Geräts Empire Comfort Systems VFCM-25-3. VFCR-25-3 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Empire Comfort Systems VFCM-25-3. VFCR-25-3 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Empire Comfort Systems VFCM-25-3. VFCR-25-3 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Empire Comfort Systems VFCM-25-3. VFCR-25-3 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Empire Comfort Systems VFCM-25-3. VFCR-25-3 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Empire Comfort Systems VFCM-25-3. VFCR-25-3 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Empire Comfort Systems VFCM-25-3. VFCR-25-3 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Empire Comfort Systems VFCM-25-3. VFCR-25-3. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Empire Comfort Systems VFCM-25-3. VFCR-25-3 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
