Benutzeranleitung / Produktwartung 917.27306 des Produzenten Craftsman
Zur Seite of 68
Owner's Manual CRnFTSMnN o 20.0 HP ELECTRIC START 50" MOWER AUTOMATIC GARDEN TRACTOm Model No. 917.273060 • Safety • Assembly • Operation • Maintenance • Repair Parts CAUTION: Read and follow all Safety Rules and Instructions before operating this equip- ment.
.... ....... .8 .......... 12 .......... 19 Maintenance ......................................... 19 Service and Adjustments ...................... 23 Storage ................................................. 31 Troubleshooting .......................
• Turn off blades when not mowing. • Stop engine before removing grass catcher or unclogging chute. • Mow only in daylight or good artificial light. • Do not operate the machine while under the influence of alcohol or drugs. • Watch for traffic when operating near or crossing roadways.
• Never make adjustments or repairs with the engine running. • Grass catcher components are subject to wear, damage, and deterioration, which could expose moving pads or allow objects to be thrown. Frequently check components and replace with manufacturer's recommended parts, when necessary.
PRODUCT SPECIFICATIONS !GASOLINE 3.5 GALLONS iCAPAC TY UNLEADED !/_ND TYPE: REGULAR DIL TYPE SAE 10W-30 _,PI-SF/SG/SH): (above 32°F) SAE 5W-30 (below 32°F) DIL CAPACITY: W/FILTER: 4.2 PINTS W/O FILTER: 3.7 PINTS SPARK PLUG: Champion RC12YC SAP: .030") 3ROUND SPEED FORWARD: 5.
PARTS BAG CONTENTS SHOWN FULL SIZE (1) Shoulder Bolt 5/16-18 © (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob i - 1_3) R_tair_erSprings (E_oubl_ Loop) I (4) Retainer Springs (Single Loop) 6.
Paris packet separately in carton Parts Bag contents not shown full size Seat Manual 7-- b V, Video Cassette Steering Wheel i I i o i i Parts Bag (_ (2) Washers 3/8, x 7/8 x 14 Ga.
Your new tractorhas beenassembled at the factorywith exception of those partsleft unassembled for shipping purposes. Toensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure propertightness.
HOW TO SET UP YOUR TRACTOR CHECK BATTERY • Lift hood to raised position. • If this battery is put into service after month and year indicated on label (label located between terminals) charge bat- tery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions).
• Raise deck to highest position. • Assemble gauge wheels as shown using long shoulder bolts, 3/8 washers, and 3/8-16 center Iocknuts. Tighten se- curely. • Adjust gauge wheels before operating mower as shown in the Operation sec- tion of this manual.
Ii CHECKLIST Please review the following checklist: / All assembly instructions have been completed. ,/No remaining loose parts in carton. ,/Battery is properly prepared and charged. (Minimum 1 hour at 6 amps). ,/Seat is adjusted comfortably and tight- ened securely.
These symbols may appear on your tractoror in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING ENGINE ON ENGINE OFF REVERSE FORWARD FAST SLOW OIL PR.
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference.
The operation of any tractor can result in foreign objects thrown into the J eyes, which can result in severe eye damage. Always wear safety glasses I or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles, or stan- dard safety glasses.
• The average lawn should be cut to approximately 2-1/2 inches during the cool season and to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, grass over 6 inches in height should be mowed twice.
NOTE: To protect hood from damage when transporting your tractor on a truck or a trailer, be sure hood is closed and secured to tractor. Use an appropriate means of tying hood to tractor (rope, cord, etc.
WARM WEATHER STARTING (50 ° F AND ABOVE) • When engine starts, slowly push choke control in until the engine begins to run smoothly. If the engine starts to run roughly, pull the choke control out slight- ly for a few seconds and then continue to push the control in slowly.
MOWING TIPS • "13re chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual.
CUSTOMER RESPONSIBILITIES FILL IN DATES _t,O_/_,_,_O"j_. You Check Operator Presence and T Veer_ck Systems I/ R Check for Loose Fasteners (l_ V_7 i Jl_ A S_arPe_Rep'_e M°wor _ades _" T.
TRACTOR Always observe safety ruleswhen per- forming any maintenance. BRAKE OPERATION If tractorrequires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. (See "3"0 ADJUST BRAKE" in the Service and Adjustments section of this manual).
NOTE: The original equipment battery on your tractoris maintenance free. Do not attempt to open or removecaps or covers. Adding or checking level of electrolyte is not necessary, TO CLEANBATTERY AND TERMINALS Corrosion and dirt on the battery and ter- minals can cause the battery to "leak" power.
CLEANAIR INTAKE/COOLING AREAS To insure proper cooling, make sure the grass screen, cooling fins, and other external surfaces of the engine are kept clean at all times. Every 100 hours of operation (more often under extremely dusty, dirty conditions), remove the blower housing and other cooling shrouds.
_CAUTION: Before performing any service or adjustments: • Depress clutch/brake pedal fully and set parking brake. • Place motion control lever in neutral (N) position. • Place attachment clutch in =DISENGAGED" position. i um ignition key =OFP and remove key.
TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PROD- UCT SPECIFICATIONS'). If tires are over or underinflated, you will not properly adjust your mower.
MOWER DRIVE BELT INSTALLATION • Install belt in both idlers. Make sure belt is in both belt keepers at the idlers as shown. • Install new bolt onto electric clutch pul- ley. • Roll belt into upper groove of left hand mandrel pulley. • Carefully check belt routing making sure belt is in the grooves correctly and inside bolt keepers.
Left Hand Mandrel Mower Blade Ddve Belt Center Mandrel Right Hand Cover Screw Idler Arm Spdng Anit-Sway Bar Idler Bracket Pulley TO ADJUST ATTACHMENT CLUTCH The electric clutch should provide years of service. The clutch has a built-in brake that stops the pulley within 5 seconds.
BELTINSTALLATION - • Place V part of belt intogrooves on engine pulley and front V-idler, making sure to route belt inside of all belt keep-_ ers, • Route belt on right side, coming from V- idler, towards back of tractor, above midspan belt keeper and to top of transaxle pulley.
Sleeves Jam Nuts TO REMOVE WHEEL FOR REPAIRS FRONT WHEEL • Block up axle securely. • Remove axle cover, retaining ring and washers to allow wheel removal. Repair tire and reassemble. Replace washers and snap retaining nng securely in axle groove. • Replace axle cover.
Keps Nut _ u..., TO REMOVE HOOD AND GRILL Terminal ..... _ _- _ .. ' '°^ ASSEMBLY A=e .... Bolt • Raise hood. Door..___."-" " - • Unsnap headlight wire connector. _Positive Stand in front of tractor. Grasp hood at :.--" sides, tilt toward engine and lift off of .
TO ADJUST CHOKE CONTROL The choke control has been preset at the factory and adjustment should not be nec- essary, check adjustment as described below before loosening cable. If adjust- ment is necessary, proceed as follows: • With engine not running, move choke control (located on dash panel) to full choke position.
Immediately prepare your tractor for stor- age at the end of the season or if the trac- tor will not be used for 30 days or more. _,CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark.
TROUBLI=SHOOTING CHART PROBLEM CAUSE Will not start • Out of fuel. • Engine not =CHOKED" prop- CORRECTION • RII fuel tank. • See =TO START ENGINE" in erly. • Engine flooded. • Bad spark plug. • Dirty air filter. • Dirty fuel filter.
TROUBLESHOOTING CHART PROBLEM CORRECTION Loss of power • CAUSE • Cutting too much grass/too fast. • Thm_e in "CHOKE" position. • Build-up of grass, leaves and trash under mower. • Dirty air filter. • Low oil level/dirty oil. • Faulty spark plug.
TROUBLESHOOTING CHART PROBLEM Mower blades will not rotate (cont'd) Poor grass discharge Heso_Ight(s) not work ing (if so equipped) Bs_ery will not charge Loss of drive Engine =backfires" when tuming engine "OFF" CAUSE • Frozen idler pulley.
TRACTOR . . MODEL NUMBER 917.273060 SCHEMATIC OPERATO_ PRESENG_ RELAY RELAy GFG IGNmON ftwrrcH R_J_IOyA_._ NON.R¢_MOVABLE CONNECTIONS B E I DA NG NE CONNECTOR L STAnT I.÷S÷All _E_) _TOR--_ ---I_at TRACTOR CONNECTOR NOTE: {F W(R(NG|NSUILATED GARBURET(}R (REO W1RE) OULD _ REPLACED TO T;_V (Ye.
ELECTRICAL TRACTOR - - MODEL NUMBER 917.273060 22 33 12 11 26 i I I i I 36.
ELECTRICAL TRACTOR - - MODEL NUMBER 917.273060 KEY NO. PART NO. DESCRIPTION 1 144927 Battery 2 74760412 Bait Hex Head 114-20x 3/4 8 7603J Tray, Battery 10 145211 Bolt 114-20 x 7.
TRACTOR - - MODEL NUMBER 917.273060 CHASSIS AND ENCLOSURES 37 122 17 ! 17 19 100 68 2 86 17 56 102 52 17.
TRACTOR - - MODEL NUMBER 917.273060 CHASSIS AND ENCLOSURES KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 1 150253 Rail, Frame RH 50 152728 2 140506 Dmwbar, Gt 52 STD541431 4 73800700 Nut, LockHex 7/16.
TRACTOR - - MODEL NUMBER 917.273060 GROUND DRIVE 42 I 9 7 61 104 2 15 47 112 IO0 4O.
TRACTOR - - MODEL NUMBER 917.273060 GROUND DRIVE KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 2 7070E Key 1/4 x 2.5 72 STD541431 3 7563R Washer, Thrust,Axle 73 744,90.
TRACTOR - - MODEL NUMBER 917.273060 STEERING ASSEMBLY 34 32 8 27 42 28 19 42.
TRACTOR - - MODEL NUMBER 917.273060 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 159944X428 2 137094 3 6855M 4 161849 5 161848 6 6266H 7 121748X 8 12000029 9 121232X 10 74781044 11 136518 12 73901.
ENGINE TRACTOR - - MODEL NUMBER 917.273060 21 _ Jl 20 3 18 15 17 47-_, 39 I _55 _19 7 38 I SPARK ARRESTER KIT I 44.
ENGINE TRACTOR - - MODEL NUMBER 917.273060 KEY PART NO. NO. DESCRIPTION 1 ...... 2 161062 5 13200300 7 151396 8 121361X 9 150828 10 105432X 11 140923 12 143996 15 151346 16 109227X 17 106082X 18 16149.
TRACTOR " - MODEL NUMBER 917.273060 SEAT ASSEMBLY KEY PART KEY PART NO. NO. NO. NO_ DESCRIPTION 14 720_:_412 1 140124 Seat 15 121249X 2 140551 i_4cket, pivot seat 16 123740X 3 140675 St_p, Fender 17 123976X 4 127018X Bo_Shoulder 5/16-18x.62 18 19171912 5 145006 Clip, Push In, t_ged 6 STD541437 Nut, Cmwnk_ 3/.
DECALS TRACTOR - - MODEL NUMBER 917.273060 18 17 4 17 10 13 7. 8 ¸ 11 12 KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 PART NO. 164094 149516 163916 163917 140837 133644 164757 164884 1632O4 156439 4900J 146790.
TRACTOR - - MODEL NUMBER 917.273060 LIFT ASSEMBLY 40 43 35 17 38 z¢; ° 70 39 23 I 13 41 _ 22 12 16 15 20 19 18 48.
TRACTOR - - MODEL NUMBER 917.273060 LIFT ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 121006X RodAsm., Lever 2 159187 ShaftAsm., Lift Vgt 3 159189 LeverAsm, Lift Rh 4 12000022 E-Ring Truam #5133-87 5 19292016 Washer 29i32xl-1/4x16Ga.
TRACTOR - - MODEL NUMBER 917.273060 MOWER DECK 64 48 55 63 i i i I i30 i 4,5 44 I 48 47 48 i 2 2 2 22 21 5O.
TRACTOR - - MODEL NUMBER 917.273060 MOWER DECK KEY PART NO. NO. 1 156990 2 STD541431 3 72110506 4 7631J 5 138457 6 STD624008 7 130832 8 850857 9 STD551137 10 140296 11 137380 12 129895 13 137553 14 13.
TRACTOR - - MODEL NUMBER 917.273060 TRANSAXLE MODEL NO. 222-3010L 20 [2) 52.
TRACTOR - - MODEL NUMBER 917.273060 TRANSAXLE MODEL NO. 222-3010L KEY PART KEY PART NO, NO. DESCRIPTION NO. NO. DESCRIPTION 1 164591 Assembly, Housing, LH 72 153767 Locknut, Hex 5/16-18 2 164592 Assembly, Housing, RH 7 153765 OilSeal .
TRACTOR - - MODEL NUMBER 917.273060 TRANSAXLE - PUMP - MODEL NUMBER BU-10L-122 54.
TRACTOR - - MODEL NUMBER 917.273060 TRANSAXLE - PUMP - MODEL NUMBER BU-10L-122 KEY PART NO. NO. DESCRIPTION 1 144569 Shaft, Pump 2 122716X Ring, Retaking 3 122745X Beadng, Ball 4 122715X Spacer 5 1227.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 CYLINDER HEAD, VALVE AND BREATHER _m13 , I 2t jlS _17 _RANCASE_J 2 56.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 HEAD/VALVE/BREATHER KEY PART NO. NO. DESCRIPTION 1 24-O33-O3 2 24-041-23 3 24-096-15 4 M-0645020 5 X-75-23 6 12-.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 IGNITION/ELECTRICAL I AIR INTAKE J BLOWER HOUSING AND BAFFLES I 12/L_ J t_--3 14 Is t3 11 58-.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 IGNmON/CHARGING BLOWER HOUSING & BAFFLES KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1 54-756-15 Kit, grass screen 1 54-027-95 (Includes 2-4,and 24 113 18) 2 M-0403025 Screw, hex.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 STARTING SYSTEM I ,< 2 5 I ENGINE CONTROLS 5 I --$ 124 22_. 18 13 )IL PAN I LUBRICATION 0 .
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 STARTING SYSTEM KEY PART NO. NO. 1 M-0839070 2 24-096-O5 3 M-0839080 4 12-468-01 5 25-098-05 6 12-221-01 7 12-227-13 8 12-211-01 9 12-755-54 10 12-227-06 11 12-170-05 ENGINE CONTROLS KEY PART NO.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 CRANKSHAFT I 2--_ --1 EXHAUST I m /2 FUEL SYSTEM I / 1 14 62.
TRACTOR - - MODEL NUMBER 917.273060 KOHLER ENGINE-MODEL NUMBER CV20S, TYPE NUMBER 65551 CRANKSHAFT KEY PART NO. NO. I 24-O14-72 2 52-139-(_ EXHAUST KEY PART NO. NO. 1 24-041-02 2 25-072-04 24-522-16 24-782-05 24-755-03 FUEL SYSTEM KEY PART DESCRIPTION NO.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION SIGHTING GUIDE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL o_ I Operate your Tractor up and down the face of slopes (not I greater than 15°), never across the face. Make turns gradu- I ally to prevent tipping or loss of control.
65.
66.
67.
Forthe repair or replacement parts you need delivered directly to your home Call 71am - 7 pm, 7 days a week 1-800-366-PART (1-800-366-7278) Para ordenar piezas con entrega a domicilio - 1-800-659-7084 For in-house major brand repair service Call 24 hours a day, 7 days a week 1-800-4-REPAIR .
Ein wichtiger Punkt beim Kauf des Geräts Craftsman 917.27306 (oder sogar vor seinem Kauf) ist das durchlesen seiner Bedienungsanleitung. Dies sollten wir wegen ein paar einfacher Gründe machen:
Wenn Sie Craftsman 917.27306 noch nicht gekauft haben, ist jetzt ein guter Moment, um sich mit den grundliegenden Daten des Produkts bekannt zu machen. Schauen Sie zuerst die ersten Seiten der Anleitung durch, die Sie oben finden. Dort finden Sie die wichtigsten technischen Daten für Craftsman 917.27306 - auf diese Weise prüfen Sie, ob das Gerät Ihren Wünschen entspricht. Wenn Sie tiefer in die Benutzeranleitung von Craftsman 917.27306 reinschauen, lernen Sie alle zugänglichen Produktfunktionen kennen, sowie erhalten Informationen über die Nutzung. Die Informationen, die Sie über Craftsman 917.27306 erhalten, werden Ihnen bestimmt bei der Kaufentscheidung helfen.
Wenn Sie aber schon Craftsman 917.27306 besitzen, und noch keine Gelegenheit dazu hatten, die Bedienungsanleitung zu lesen, sollten Sie es aufgrund der oben beschriebenen Gründe machen. Sie erfahren dann, ob Sie die zugänglichen Funktionen richtig genutzt haben, aber auch, ob Sie keine Fehler begangen haben, die den Nutzungszeitraum von Craftsman 917.27306 verkürzen könnten.
Jedoch ist die eine der wichtigsten Rollen, die eine Bedienungsanleitung für den Nutzer spielt, die Hilfe bei der Lösung von Problemen mit Craftsman 917.27306. Sie finden dort fast immer Troubleshooting, also die am häufigsten auftauchenden Störungen und Mängel bei Craftsman 917.27306 gemeinsam mit Hinweisen bezüglich der Arten ihrer Lösung. Sogar wenn es Ihnen nicht gelingen sollte das Problem alleine zu bewältigen, die Anleitung zeigt Ihnen die weitere Vorgehensweise – den Kontakt zur Kundenberatung oder dem naheliegenden Service.
